硅烷浓度对微晶硅太阳电池的影响  

Influence of Silane Concentration on the Performance of Microcrystalline Silicon Cells

作　　者：高艳涛[1,2,3] 张晓丹[1,2,3] 朱锋[1,2,3] 魏长春[1,2,3] 孙建[1,2,3] 赵颖[1,2,3] 

机构地区：[1]南开大学光电子薄膜器件与技术研究所,天津300071 [2]南开大学光电子薄膜器件与技术天津市重点实验室,天津300071 [3]光电信息技术科学教育部重点实验室(南开大学,天津大学)

出　　处：《人工晶体学报》2006年第3期514-517,共4页Journal of Synthetic Crystals

基　　金：国家"973"重大基础研究发展规划项目(No.G2000028202;G2000028203);天津科委攻关项目(No.043186511);国家自然科学基金(No.60506003);天津市国际科技合作项目(No.05YFGHHZ01400)

摘　　要：采用甚高频等离子化学气相沉积技术(VHF-PECVD)制备了系列p-i-n型微晶硅太阳电池,研究了电池有源层硅烷浓度的变化对电池性能的影响。结果发现:随着硅烷浓度的提高电池的短路电流密度先提高然后降低,转换效率与之有相同的变化趋势,而开路电压随硅烷浓度的提高而增加,这些变化来源于有源层材料结构的改变。电池的填充因子几乎不受硅烷浓度的影响,但受前电极的影响很大。不同系列电池转化效率的最高点虽然处于非晶到微晶的过渡区,但对应电池的晶化率不同。另外,研究结果也给出非晶/微晶过渡区随着辉光功率的提高和沉积气压的降低向高硅烷浓度方向转移。Several series of p-i-n solar cells were prepared by very high frequency plasma enhanced chemical vapor deposition （VHF-PECVD） technique. The effect of silane concentration of the active layer on the performance of microcrystalline solar cells was investigated. The results indicate that both short circuit density （Jsc） and conversion efficiency increase firstly and then decrease with the increase of silane concentration. However the open circuit voltage （Voc） increases with increasing the silane concentration. These changes result from the structural change of active layer. The silane concentration has little effect on the fill factor of solar cells. But it is strongly affected by the type of front electrode. They have different crystalline volume fractions （Xc） although the optimum points of conversion efficiency of solar cells are all located at the transition zone from amorphous silicon to microcrystalline silicon. In addition, the results also demonstrate that the transition zone shifts to the higher silane concentration with increasing discharge power or decreasing deposition pressure.

关 键 词：甚高频等离子化学气相沉积 微晶硅太阳电池 硅烷浓度 

分 类 号：TK511[动力工程及工程热物理—热能工程]