串行流化床稻秸气化合成甲醇的模拟  

Simulation of Methanol Production Via Rice Straw Gasification in Interconnected Fluidized Beds

作　　者：张亚男[1] 肖军[1] 沈来宏[1] 

机构地区：[1]东南大学热能工程研究所,江苏省南京市210096

出　　处：《中国电机工程学报》2009年第32期103-111,共9页Proceedings of the CSEE

基　　金：国家自然科学基金项目(20590367;50306002);国家重点基础研究发展计划项目(973项目)(2007CB210208)~~

摘　　要：以秸秆为研究对象,利用Aspen Plus软件建立串行流化床稻秸气化制取富氢气体合成甲醇的模型,研究不同反应条件包括气化温度、气化压力、水蒸气与生物质(稻秸)的配比、液化温度及液化压力对甲醇产率的影响。结果表明:采用串行流化床稻秸水蒸气气化技术可获得氢浓度为55%以上的富氢燃气;在C301铜基催化剂作用下,对于以制甲醇为目的的串行流化床稻秸气化系统,气化温度建议在750℃左右,气化压力尽量接近常压,水蒸气与生物质配比在0.4～0.5内为佳,液化温度建议控制在220～240℃,液化压力为5MPa;在此最佳工况下,每千克的干燥无灰基稻秸可获得11.97mol的最大甲醇产量。研究成果为今后开展生物质气化及气化产气合成甲醇实验提供理论依据。Simulation of methanol synthesis via H2-rich syngas from rice straw gasification in interconnected fluidized beds was carried out, using Aspen Plus software to establish this model. Effects of operating parameters, including gasification temperature and pressure, steam /biomass （S/B） （rice straw） ratio, liquefaction temperature and pressure, on the methanol yield were analyzed. The results show that rice straw steam gasification can obtain 55% hydrogen-rich gas and when the C301 Cu-based catalyst was adopted as the methanol synthesis catalyst, the gasification temperature is suggested to be controlled at about 750℃ in the interconnected fluidized beds rice straw gasification system with the purpose of methanol production. Furthermore, the gasification pressure is proposed to approach to the ambient pressure and the SIB ratio of 0.4-0.5 operates better. The liquefaction temperature is proposed to be controlled between 220 and 240℃ and the liquefaction pressure of 5 MPa is adopted. On the optimal operating condition, the maximum of 11.97 mol per kg rice straw （daf） of methanol yield may be obtained. The research provides useful datas for the further study on biomass gasification and methanol synthesis from biomass syngas.

关 键 词：稻秸气化 甲醇 串行流化床 模拟 

分 类 号：TK6[动力工程及工程热物理—生物能]