TAED氧漂稳定性与活化性能的光谱分析  

Research on stability and activation performance of oxygen bleaching activator TAED by spectral analysis

作　　者：李青[1] 唐人成[1] 沈自祥 

机构地区：[1]现代丝绸国家工程实验室,苏州大学,江苏苏州215123 [2]浙江金科化工股份有限公司,浙江上虞312369

出　　处：《印染》2010年第22期1-5,共5页China Dyeing and Finishing

基　　金：国家科技支撑计划项目(编号2007BAE41B40)

摘　　要：采用紫外吸收光谱和红外光谱分析法,研究了低温氧漂活化剂四乙酰乙二胺(TAED)对温度和酸碱度的稳定性。TAED水溶液在温度30～95℃下稳定性好;在酸性条件下稳定,在碱性条件下易水解,碱浓度越高,水解程度越大。碱性条件下,TAED的水解反应与活化双氧水的反应为:中碱性(pH值11～12)条件下,从30℃升温至50℃的前10 min内,水解反应速率很快;弱碱性(pH值8～10)条件下,从30℃升温至70℃的前20 min内,活化反应速率很快。不同pH值下棉针织布的漂白试验结果表明,双氧水/TAED活化体系的初始pH值控制在8左右能获得很好的漂白效果。The stability of the low-temperature oxidation bleach activator tetraacetylethylennedianime （TAED） under different temperature and pH value was investigated by FT-IR and UV spectral analysis. Aqueous solution of TAED was stable at the temperature of 30 ~95℃ the stability of TAED was better in the acidic solution than in the alkaline solution; the degree of its hydrolysis became greater with the increased concentration of alkali. The hydrolysis of TAED and its activation to hydrogen per- oxide were researched under alkaline condition. The hydrolysis in the medium alkaline condition was carried out quickly within the former lOmin from 30 ℃ to 50 ℃. The rate of activating reaction was fast under weak alkaline condition within the former 20min from 30 ℃ to 70 ℃. The bleaching result of cotton knitgoods under different pH value indicated that the hydrogen perox- ide/TAED activating system can obtain excellent bleaching effect when the initial pH value maintained about 8.

关 键 词：氧化漂白 过氧化氢 四乙酰乙二胺 稳定性 水解 光谱法 

分 类 号：TS192.2[轻工技术与工程—纺织化学与染整工程]