微孔曝气器充氧性能变化对污水处理厂能耗的影响  

Influence of oxygenation capacity of fine bubble aerator on energy consumption in wastewater treatment plant

作　　者：梁远[1] 王佳伟[1] 李洁[1] 应启峰[1] 卢长松[1] 谢继荣[1] 胡俊[1] 

机构地区：[1]北京城市排水集团有限责任公司,北京100022

出　　处：《给水排水》2011年第1期42-45,共4页Water & Wastewater Engineering

基　　金："十一五"国家科技支撑计划重点资助项目(2006BAC19B06)

摘　　要：以北京小红门污水处理厂的新、旧刚玉盘式微孔曝气器为例,进行曝气充氧性能的试验研究,并分析了更换曝气器对污水处理厂能耗的影响。结果表明:经过长期使用的曝气器充氧性能下降较大,氧总转移系数、氧的利用效率和动力效率分别下降了57%、58%和59%。旧微孔曝气器氧的利用效率为8.9%～14.1%,略高于中大气泡曝气器的性能参数,但由于微孔曝气器具有较大的阻力损失,使旧微孔曝气器的动力效率为1.5～2.1kgO2/(kW.h),低于中大气泡曝气器的性能参数。更换小红门全厂1/4的微孔曝气器后,鼓风机单耗降低21%,全厂能耗降低12%。因此,当微孔曝气器的充氧性能下降较大时,更换新的曝气器具有较高的节能和经济效益。Taking the new,old corundum fine bubble aerator in Xiaohongmen Wastewater Treatment Plant（WWTP）as a case study,this paper carried out the oxygenation capacity experimental study and analyzed the influences of changing aerator on WWTP energy consumption.The results showed： after long-term usage,the oxygenation capacity of aerator decreased relatively rapidly,and the total oxygen transfer coefficient,oxygen utilization efficiency,and dynamic efficiency decreased by 57%,58%,and 59% respectively.The oxygen utilization efficiency of old fine bubble aerator was 8.9%~14.1%,which was a little bit above the characteristic parameter of the middle and large-size bubble aerator.But due to the relatively high resistance loss of fine bubble aerator,the dynamic efficiency of old fine bubble aerator was only 1.5~2.1 kgO2/（kW·h）,lower than the middle and large-size bubble aerator.After replacing the quarter of old fine bubble aerators with new ones,the blast blower energy consumption decreased by 21%,and the total plant energy consumption decreased by 12%.So,when the fine bubble aerators oxygenation capacity decreased greatly,replacing them with new ones will has relatively high energy-saving and economic benefits.

关 键 词：污水处理厂 微孔曝气器 氧的利用效率 动力效率 氧总转移系数 

分 类 号：X505[环境科学与工程—环境工程]