含低剂量抑制剂体系气体水合物生成动力学  

Kinetic studies of gas hydrate formation with low dosage hydrate inhibitors

作　　者：唐翠萍[1,2] 戴兴学[1,2] 杜建伟[1,2] 李栋梁[1,2] 臧小亚[1,2] 杨向阳[1] 梁德青[1] 

机构地区：[1]中国科学院广州能源研究所中国科学院可再生能源及天然气水合物重点实验室,广州510640 [2]中国科学院研究生院,北京100039

出　　处：《中国科学：化学》2011年第1期145-151,共7页SCIENTIA SINICA Chimica

基　　金：国家自然科学基金(50906087)资助

摘　　要：水合物管道堵塞是油气工业安全生产的重要问题之一,目前低剂量抑制剂以其经济性、环境友好性等优点,逐步取代传统抑制剂.文中在8.5MPa、4℃条件下,1.072L反应釜内,采用甲烷、乙烷和丙烷混和气,研究了含低剂量抑制剂聚乙烯吡咯烷酮(PVP)和GHI1的水合物生成体系反应过程,计算分析了压缩因子和自由气量随反应时间的变化,对比了在相同反应程度下添加PVP和GHI1后水合物含气量的区别,探讨了GHI1组合抑制剂的抑制机理实验结果表明PVP和GHI1能抑制水合物生长,不能有效抑制水合物成核;添加PVP的体系在实验气体组成下,甲烷乙烷进入水合物小晶穴,并且甲烷优先进入小晶穴;GHI1对丙烷乙烷的抑制能力强于甲烷;对比GHI1和PVP的反应过程,认为协同剂二乙二醇丁醚的羟基和醚类结构加强反应体系中的氢键,和PVP结合使用,通过氢键和空阻达到抑制效果.Pipeline blockage by gas hydrates is a serious problem in the petroleum industry. Low-dosage inhibitors have been developed for its cost-effective and environmentally acceptable characteristics. In a 1.072-L reactor with methane, ethane and propane gas mixture under the pressure of about 8.5 MPa at 4 ~C, hydrate formation was investigated with low-dosage hydrate inhibitors PVP and GHI1, the change of the compressibility factor and gas composition in the gas phase was analyzed, the gas contents in hydrates were compared with PVP and GHI1 added, and the inhibition mechanism of GHI1 was discussed. The results show PVP and GHI1 could effectively inhibit the growth of gas hydrates but not nucleation. Under the experimental condition with PVP added, methane and ethane occupied the small cavities of the hydrate crystal unit and the ability of ethane entering into hydrate cavities was weaker than that of methane. GHI1 could effectively inhibit molecules which could more readily form hydrates. The ether and alcohol structures of diethylene glycol monobutyl ether have the responsibility for stronger inhibition ability of GHI1 than PVP.

关 键 词：低剂量抑制剂 水合物 反应时间 

分 类 号：TE88[石油与天然气工程—油气储运工程]