MICR反应器处理淀粉废水的启动实验研究  

Experimental study on start-up of starch wastewater treatment in MICR

作　　者：李平[1] 冼萍[1] 邓慧[1] 熊佐芳[1] 陈伟强[1] 

机构地区：[1]广西大学环境学院,广西南宁530004

出　　处：《广西大学学报（自然科学版）》2011年第3期513-517,共5页Journal of Guangxi University（Natural Science Edition）

基　　金：广西科学研究与技术开发计划项目(桂科攻0816002-5)

摘　　要：采用淀粉废水对多相串联内循环厌氧反应器(MICR,multi-internal-circle reactor)的启动特性进行实验研究,旨在为该反应器的实际应用和工艺优化提供理论依据。结果表明,经过58 d的启动,当进水的化学需氧量(CODCr)浓度为3 500 mg/L、水力停留时间(HRT)为24 h、相应的容积负荷为3.5 kgCOD/(m3.d)时,CODCr去除率稳定在94.5%左右,1﹟、2﹟、3﹟反应室CH4容积产气率分别为0.15、0.23、0.08 m3/(m3.d),反应器启动成功。系统出水pH值稳定在7.5左右,碱度保持在1 370 mg/L左右,具有较强的缓冲能力。反应器底部污泥颗粒化良好,粒径在2.0～3.5 mm,沉降性好。Start-up of starch wastewater treatment in a multi-internal-circle reactor（MICR） was experimentally studied,aiming at giving theoretical basis to its application and optimizing the process.The results indicated that when the influent concentration of CODCr was 3 500 mg/L,the HRT was 24 h,and the volume loading rate was 3.5 kgCOD/（m^3·d）accordingly,after 58 days of start-up,the removal rate of CODCr was 94.5% and stable,the volumetric gas production rate of CH4 in each compartment（1^﹟、2^﹟、3^﹟） reached 0.15,0.23,0.08 m^3/（m^3·d）,respectively,thus,indicating that the MICR was successfully started-up.The pH value and the alkalinity were stabilized at about 7.5 and 1 370 mg/L respectively in the final effluent.MICR had a good resistance and self-repairing capability.The bottom sludge of the reactor were transformed into granular sludge,which had a good sedimentation capability with the diameters ranging from 2.0 mm to 3.5 mm.

关 键 词：MICR反应器 淀粉废水 启动 颗粒污泥 

分 类 号：X703[环境科学与工程—环境工程]