掺ZBS玻璃低温烧结YIG铁氧体及其磁性能研究  

Study on the Low-Temperature Firing and Magnetic Properties of YIG Ferrites Doped with ZBS Glass

作　　者：徐光亮[1] 曾丽文[1] 刘桂香[1] 余洪滔[1] 陈劲松[2] 

机构地区：[1]西南科技大学新材料研究所,材料科学与工程学院,四川省非金属复合与功能材料重点实验室-省部共建国家重点实验室培育基地,四川绵阳621010 [2]西南应用磁学研究所,四川绵阳621000

出　　处：《压电与声光》2012年第1期96-99,共4页Piezoelectrics & Acoustooptics

基　　金：国家自然科学基金资助项目(10704061);四川省教育厅重点基金资助项目(08ZA009);西南科技大学研究生创新基金资助项目(10ycjj14)

摘　　要：采用普通陶瓷工艺,分别制备了不同ZnO-B2O3-SiO2(ZBS)玻璃掺量的Y3Fe5O12(YIG)和Y1.05Bi0.75Ca1.2Fe4.4V0.6O12(YBiCaVIG)铁氧体样品。分析了样品的物相组成、显微结构及磁性能。结果表明,ZBS玻璃能有效地降低YIG和YBiCaVIG陶瓷的烧结温度,当w(ZBS)=10%时,其烧结温度可分别降低到1 280℃和950℃,但XRD显示烧结体中分别出现少量SiO2和YFeO3(YIP)杂相,SEM显示样品的晶粒大小约2～4μm,气孔率偏高。添加ZBS玻璃后材料的饱和磁化强度4πMs下降,铁磁共振线宽ΔH增大,但由于烧结体晶粒较细,自旋波线宽ΔHk较大,可作为YIG大功率材料使用。The Y3Fe5O12（YIG） and Y1.05Bi0.75Ca1.2Fe4.4V0.6O12（YBiCaVIG） ferrites doped with different ZnO-B2O3-SiO2（ZBS） glass contents has been prepared by the common ceramics method.The phase composition,microstructure and magnetic properties of the samples were investigated.It was found that ZBS glasscould effectively decrease the sintering temperature of YIG and YBiCaVIG ceramics.When the doping content of ZBS was w（ZBS）=10%,the sintering temperature of YIG and YBiCaVIG ceramics could be reduced to 1 280 ℃ and 950 ℃ respectively.But the XRD patterns showed that a few SiO2 and YFeO3（YIP） impurities were formed,meanwhile,the SEM showed that the samples have the grain size of about 2~4 μm and higher pores rate.After doping ZBS glass,the saturation magnetizations 4πMs decreased while the ferromagnetic resonance line width ΔH increased.However,since the samples have bigger spin wave line width ΔHk and smaller grain size,they are suitable for large power YIG materials.

关 键 词：Y3Fe5O12(YIG)铁氧体 ZnO-B2O3-SiO2(ZBS)玻璃 低温烧结 磁性能 

分 类 号：TM277.3[一般工业技术—材料科学与工程]