Pd和K共负载的Mg-Al水滑石基氧化物同时去除碳烟和NO_x  

Simultaneous Catalytic Removal of Diesel Soot and NO_x over Pd and K Co-Supported Mg-Al Hydrotalcite Oxides

作　　者：张业新[1] 苏庆运[1] 王姿姿[2] 王仲鹏[2] 李倩[2] 高希彦[1] 张昭良[2] 

机构地区：[1]大连理工大学内燃机研究所,大连116024 [2]济南大学化学化工学院,济南250022

出　　处：《燃烧科学与技术》2012年第1期56-61,共6页Journal of Combustion Science and Technology

基　　金：国家高技术研究发展计划(863计划)资助项目(2008AA06Z320);国家自然科学基金资助项目(20777028;21007109;21077043;50906008);山东省优秀中青年科学家奖励基金资助项目(BS2009HZ010);清华大学汽车安全与节能国家重点实验室开放基金资助项目(KF11182)

摘　　要：采用浸渍法将Pd和K共同负载到Mg-Al水滑石基氧化物(Pd-K/MgAlO)上,用于碳烟颗粒和NOx的同时去除,并与Pd/MgAlO和K/MgAlO催化剂进行了比较.研究发现,单独的Pd负载不具备催化碳烟燃烧的活性,但可以提高生成CO2的选择性;引入NOx后,Pd可以通过促进NO氧化对碳烟燃烧有所改善,同时可以去除少量的NOx.当Pd与K共负载时,碳烟燃烧温度显著降低;引入NOx后,起燃温度进一步降低至240,℃左右,而且碳烟燃烧受接触方式的影响不大,其中催化作用的主要影响组分是K.在Pd和K协同作用下,NOx的最大去除效率达到45%,高于Pd/MgAlO和K/MgAlO的去除效率.其中,一部分NOx被碳烟还原,另一部分则发生了分解反应.The Pd and K co-supported Mg-A1 hydrotalcite oxides （Pd-K/MgA10） were prepared by impregnation method. The activities of the catalyst were investigated for simultaneous catalytic removal of diesel soot and NO~. For comparison, Pd/MgAIO and K/MgA10 were also studied. The loading of Pd is not effective for catalytic soot com- bustion but can improve the selectivity for CO2. With the introduction of NOx, however, Pd/MgA10 shows a small increase in activity by promoting the oxidation of NO to NO2. Simultaneously, a limited amount of NOx is removed. When Pd and K coexist, the temperatures of soot combustion are significantly decreased. Furthermore, the ignition temperature can be further lowered to 240 ~C by the introduction of NOx. The effect of contact types between the cata- lyst and the soot is decreased. The activity of Pd-K/MgAIO for soot combustion is attributed to K rather than to Pd. Due to the existence of the synergism between Pd and K, the maximum conversion of NOx reaches 45%, higher than that of Pd/MgA10 or K/MgA10. The high conversion of NOx during soot combustion in NOx and 02 atmosphere is ascribed not only to the reduction of NOx with soot but also to the decomposition of NOx.

关 键 词：钯 钾 Mg-Al水滑石基氧化物 同时催化去除 碳烟 氮氧化物 

分 类 号：X51[环境科学与工程—环境工程]