清浊分流条件下的混凝-臭氧处理棉针织印染清废水  

Treatment of light polluted wastewater from cotton knitting dyeing and finishing by coagulation-ozone oxidation process with wastewater source separation

作　　者：赖冬麟[1,2] 周律[2] 李涛[2] 李思敏[1] 赵雪峰[3] 

机构地区：[1]河北工程大学城市建设学院,邯郸056038 [2]清华大学环境学院,北京100084 [3]北京国环清华环境工程设计研究院有限公司,北京100084

出　　处：《环境工程学报》2012年第11期3861-3866,共6页Chinese Journal of Environmental Engineering

基　　金：国家"水体污染控制与治理"科技重大专项(2009ZX07529-003)

摘　　要：根据污染源头控制和废水回用的要求,对典型棉针织染整厂的不同生产过程废水排水水质特征进行了统计分析,提出了较实用的废水源头清浊分流方案。在此基础上重点研究了混凝-臭氧组合工艺对清废水处理效果,确定了最优的工艺条件。结果表明,清废水主要为洗水,占废水总量的25%～30%;混凝-臭氧组合工艺的最优工艺条件为:pH为6～9,PAC投加量为48 mg/L,PAM投加量为1.0 mg/L,臭氧接触时间为12 min(臭氧浓度为14.5 mg/L),这时,清废水COD、色度去除率分别为71%和98%,实践证明,出水水质完全能够满足染整生产。After the wastewater discharge characteristics from the different cotton knitting dyeing and finishing production process in textile factory were investigated,source separation between the light and heavy polluted wastewater was proposed.Aimed at increasing reuse rate,the process availability using the coagulation-ozone oxidation for treating the light polluted wastewater was conducted.The results showed that the 25% ~ 30% of total wastewater amount was light polluted wastewater and mainly washing water;and the best removal rates of COD and color were over 71% and 98%,respectively,under using coagulation and ozone combined process with pH at 6~9,PAC dosage of 48 mg/L,PAM of 1.0 mg/L,and ozone concentration of 14.5 mg/L with 12 min contact time.Practice has proved that the treated water met the water quality demands of dyeing and finishing very well.

关 键 词：棉针织染整废水 清污分流 清废水 混凝 臭氧 回用 

分 类 号：X703[环境科学与工程—环境工程]