不同化学方法对印染、造纸废水的深度处理研究  

Advanced Treatment of Printing & Dyeing Wastewater and Papermaking Wastewater by Three Chemical Methods

作　　者：苌道松[1] 张昊[1] 徐颖[1] 李雪玲[1] 任四伟[1] 陈宣宇[1] 蒿洪欣[1] 许园园[1] 杨清香[1] 

机构地区：[1]河南师范大学生命科学学院,河南新乡453007

出　　处：《河南师范大学学报（自然科学版）》2012年第6期117-121,共5页Journal of Henan Normal University(Natural Science Edition)

基　　金：河南省杰出青年基金(104100510006);国家自然科学基金(21077032)

摘　　要：采用Fenton试剂氧化法、NaClO氧化法、KAl(SO4)2混凝沉淀法分别对新乡市某印染厂和某造纸厂的二级生化出水进行深度处理.考察了废水初始pH,3种试剂投加量对废水COD和色度的影响.研究结果表明:室温下,反应时间30min,3种方法对印染废水、造纸废水的深度处理均具有明显效果.Fenton试剂氧化法对两种废水的处理效果明显优于另外两种方法,其对印染废水深度处理的最适条件为:pH 4,H2O20.8mg·L-1、FeSO4150mg·L-1,COD、色度去除率分别达到81.5%、75.0%,COD和色度分别从243mg·L-1、128降至45mg·L-1、32;其对造纸废水深度处理的最适条件为pH 4,H2O20.6mL·L-1、FeSO4200mg·L-1,COD、色度去除率分别达到73.8%、75.0%,COD和色度分别从351mg·L-1、128降至92mg·L-1、32.两种废水经过Fenton试剂氧化法处理后完全可以达到地方工业行业废水排放标准.The methods of Fenton reagent oxidation, NaC10 oxidation and KAI（SO4 ）2 coagulating sedimentation were compared for advanced treatment of the effluents from the biochemical treatment system in a printing ＆. dyeing factory （PD） and a paper making （PM） plant respectively. Effects of the initial pH, the dosage of three reagents on the removal of COD and colority were studied. The results showed that the three chemical methods had obvious effects on the advanced treatment of the both wastewater at room temperature and 30 minutes reaction period. Among them, Fenton oxidation was significantly more effective in COD and color removal than the other chemical methods. Under the optimal condition of pH 4, H2O2 0.8 mL L 1 , FeS04 150 mg·L-1 , the COD and color removal rate of 81.5% and 75% were obtained permitting COD and colority reduction from 243 mg· L-1 to 45 mg· L1 and from 128 to 32, respectively for PD wastewater. Under the optimal condition of pH 4, H2（）2 0.6 mL ·L-1 , FeSO4 200 mg L-1 , the COD and color removal rate reached 73.80/oo and 75.0% for PM wastewater re suhing in COD and colority reduction from 351 mg · L-1 to 92 mg ·L-1 and from 128 to 32 dilute, respectively. After treatment by Fenton oxidation, both the PD and PM wastewater could satisfy the local industrial wastewater discharging standards.

关 键 词：FENTON氧化 NaClO氧化 混凝沉淀 废水深度处理 

分 类 号：X703.1[环境科学与工程—环境工程]