水热法制备稀土元素掺杂二氧化锡及其对乙醇气敏性能  

Synthesis of SnO2 Powder Doped with Rare Earth Elements by Hydro-thermal Method and Its Gas Sensing Properties towards Ethanol

作　　者：宋金玲[1,2] 郭冠铭[1] 周长才 牟连维 蔡颖[1,2] 张胤[1,2] 

机构地区：[1]内蒙古科技大学稀土学院,内蒙古包头014010 [2]内蒙古科技大学内蒙古自治区白云鄂博矿多金属资源综合利用重点实验室,省部共建国家重点实验室培养基地,内蒙古包头014010 [3]内蒙古中煤蒙大新能源化工有限公司,内蒙古鄂尔多斯017307

出　　处：《过程工程学报》2013年第3期531-535,共5页The Chinese Journal of Process Engineering

基　　金：内蒙古自治区高等学校科学研究资助项目(编号:NJZY13141);蒙古科技大学创新基金资助项目(编号:81111508);大学生科技创新基金资助项目(掺杂稀土SnO2材料的制备及其传感性能测试)

摘　　要：利用水热法制备了SnO2粉末及掺杂不同稀土离子的SnO2粉末.通过XRD和气敏测试仪对其结构和性能进行了表征和测试.结果表明,所制备的SnO2粉末呈四方金红石结构,稀土离子的掺入并没有改变SnO2的晶体结构,也无新晶相的出现.掺杂镧的SnO2样品(SnO2:La)对乙醇有较高的气敏性.分析了气敏机理.SnO2:La的灵敏度随着乙醇浓度的增加而增加,随温度的升高呈现波动状,且当温度在250℃时,SnO2:La对1.00×104乙醇的灵敏度最大,可达到101.1.在此条件下其响应时间和恢复时间约为5s.SnO2 and rare earth-doped SnO2 powders were prepared by hydro-thermal method, and their structures and gas sensing properties characterized by XRD and gas sensing instrument, respectively. The results show that the prepared SnO2 powder exhibits tetragonal rutile structure and rare earth ions doping do not change its crystalline structure without formation of new phases. SnO2：La exhibits better sensitivity towards ethanol. The gas sensing mechanism is analyzed. In addition, the corresponding sensitivity of SnO2：La increases with increasing of ethanol concentration and fluctuates with rising of temperature. The sensitivity of SnO2：La towards 1.00× 10-4 ethanol obtains 101.1 at 250 ℃, which is the best. The response time and recovery time are about 5 s under the condition.

关 键 词：水热法 SNO2 SNO2 La 气敏性 

分 类 号：TB383[一般工业技术—材料科学与工程]