大型潜水轴流泵转子部件湿模态数值模拟  

Numerical simulation on modal of large submersible axial-flow pump rotor

作　　者：施卫东[1] 郭艳磊 张德胜[1] 孟凡有[2] 蒋文军[2] 

机构地区：[1]江苏大学流体机械工程技术研究中心、国家水泵及系统工程技术研究中心,镇江212013 [2]江苏亚太泵阀有限公司,泰州225400

出　　处：《农业工程学报》2013年第24期72-78,F0004,共8页Transactions of the Chinese Society of Agricultural Engineering

基　　金：江苏省科技成果转化专项资金项目(BA2011126);国家科技支撑计划资助项目(2011BAF14B01);中国博士后基金面上和特别资助项目(2011M500117、2012T50468)资助

摘　　要：为了得到大型潜水轴流泵在水介质中的模态分布,并分析水介质对结构模态的影响,该文采用UDF二次开发,运用ANSYS WORKBENCH和APDL命令流耦合的方法,对特大型潜水轴流泵的轴系转动部件进行了考虑预应力情况下的湿模态数值模拟,分别计算了定常和非定常状态下预应力和不存在预应力情况下的固有频率和振型,以及转子部件在真空(干模态)和清水介质(湿模态)中的固有频率和振型,研究了预应力和清水介质对结构模态的影响。分析了不同情况下造成模态分布差异的原因,为下一步进行更加复杂的动力学分析、疲劳分析以及结构优化奠定基础。Based on method of fluid-solid coupling, a model of the large submersible axial-flow pump （1600QZ55-1100） rotating component which contains an impeller,axis and hub was studied by means of a second development of UDF and coupling WORKBENCH with APDL command. It obtained the natural frequencies and mode of vibration of a rotating component in a vacuum with pre-stress was considered, and pre-stress was not considered. Furthermore, it also achieved the natural frequencies and mode of vibration of a rotating component in water with pre-stress considered. All the above were studied in a steady condition. However, the axial-flow pump works in an unsteady condition in fact. This paper studied the effect of an unsteady condition on the structure mode too. The result showed that the natural frequencies of considering pre-stress in a steady condition are larger than those of not considering pre-stress, especially that the natural frequency corresponding to a longitudinal mode of vibration is 20%larger in a condition of considering pre-stress, and the natural frequencies of a structure in water decrease by about 10% compared with those in a vacuum. On the other hand, the first-order natural frequency in unsteady condition changes periodically with time, yet the range of that is so narrow that it could be regarded as steady. The narrow range of the first-order natural frequency that results from the range of the force on a structure in an unsteady condition is pretty narrow, compared with the huge axial force. It proved that the result in a steady condition was correct. The reason that caused the natural frequencies to increase with pre-stress considered in a vacuum is that the force on the structure results in the stress stiffening of structure, so that the stiffness of the structure in all directions is enhanced, especially the huge axial force on the structure lead to the natural frequencies increasing by 20% corresponding to a longitudinal mode of vibration. The effect of the damping of water was the main reason that

关 键 词：泵 转子 模态分析 固有频率 流固耦合 振型 

分 类 号：TH312[机械工程—机械制造及自动化]