工厂化循环水养殖中臭氧/紫外线反应系统的水处理性能  

Water treatment performance of O_3/UV reaction system in recirculating aquaculture systems

作　　者：管崇武[1,2] 杨菁[1] 单建军[1] 张海耿[1] 刘晃[1] 王欣[2] 

机构地区：[1]农业部渔业装备与工程技术重点实验室,中国水产科学研究院渔业机械仪器研究所,上海200092 [2]上海理工大学医疗器械与食品学院,上海200093

出　　处：《农业工程学报》2014年第23期253-259,共7页Transactions of the Chinese Society of Agricultural Engineering

基　　金："十二五"国家科技支撑计划项目(2012BAD25B03);农业部渔业装备与工程重点开放实验室开放课题(2010A06);上海市科技兴农重点攻关项目(沪农科攻字(2013)第3-4号)

摘　　要：为增强臭氧在水产应用的安全性,满足工厂化循环水养殖对有机物去除和水体消毒的需要,该文开发O3/UV反应系统。通过试验方法研究该系统臭氧投加溶解区适宜的臭氧投加流量和处理量的关系、紫外辐射剂量配比等工艺参数,及对水质净化效果和水体消毒灭菌效果的影响等。试验结果表明:1)在满足所需水中溶解臭氧浓度的条件下,采用较低臭氧进气流量和较高进水流量有利于提高系统的臭氧溶解率和利用率。该系统在水流量为5 m3/h,臭氧投加量为(8.78±0.60)g/h时可得到水中臭氧溶解质量浓度为1.53 mg/L的臭氧水,臭氧溶解率为82.7%,臭氧利用率为97.7%。2)增加紫外灯的功率和数量均可提高对臭氧的去除率,但增加紫外灯的数量对其性能提升效果更明显。该系统在紫外剂量为1 996 MJ/cm2,对残留臭氧的去除率为83.82%。3)该系统对紫外消光度、总有机碳、水色等指标的去除率相比单独使用臭氧分别提升109.95%、89.77%和51.44%,杀菌率可达97%以上,实现工厂化循环水养殖低臭氧残留条件下的有机物有效去除和消毒杀菌。In order to improve the water treatment performance of ozone in recirculating aquaculture systems, and enhance its application safety in the field of aquaculture, the O3/UV integration reaction system were designed. The reaction system was mainly composed of ozone addition dissolved area, ultraviolet catalytic reaction area, stay reaction area. The system was 1 250 mm of high, 750 mm in diameter, and the ultraviolet catalytic reaction was 400 mm in diameter. The working principle of system was that using static mixer way to add ozone, which could dissolve wastewater high efficiency and low energy consumption in ozone addition dissolved area. The wastewater with not completely dissolved ozone bottom up entered to ultraviolet catalytic reaction area, which could generate two advantages. On one hand, under the ultraviolet catalysis, the stronger oxidizing of hydroxyl was produced in further reaction, accelerated the rate of degradation of organic matter, and enhanced the effect of disinfection sterilization. On the other hand, it could reduce the residual amount of ozone in cultivation water, which improved the safety of the device. After treating in ultraviolet catalytic reaction area, the wastewater enter into the reaction area, which the main purpose was to keep a certain residence time of wastewater, and to improve the purification effect of degradation of organic matter and the ammonia nitrogen removal. The relationship of the suitable ozone dosage and wastewater treatment capacity in the ozone additive dissolved area, the process parameters about the ratio of ultraviolet radiation dose and the influence factors of wastewater purification and disinfection sterilization were studied through the test method. The experimental results showed that： 1） Under the condition of meeting with a certain water of dissolved ozone concentration, it could improve ozone dissolution rate and utilization rate through using low ozone inlet flow rate and low water flow. When the wastewater flow was 5 m3/h and the ozone dosage w

关 键 词：水处理 废水 臭氧 O3/UV反应系统 高级氧化技术 有机物去除 消毒灭菌 工厂化循环水 

分 类 号：X714[环境科学与工程—环境工程]