旋转失速条件下离心泵隔舌区动静干涉效应  

Impeller-volute interaction around tongue region in centrifugal pump under rotating stall condition

作　　者：周佩剑[1] 王福军[1] 姚志峰[1] 

机构地区：[1]中国农业大学水利与土木工程学院,北京100083

出　　处：《农业工程学报》2015年第7期85-90,共6页Transactions of the Chinese Society of Agricultural Engineering

基　　金：国家自然科学基金重点项目(51139007;51321001);国家科技支撑计划课题(2015BAD20B01)

摘　　要：为研究旋转失速条件下离心泵隔舌区动静干涉效应和流动特性,采用大涡模拟方法对一离心泵进行了数值模拟,得到了水泵内部流场和隔舌区压力脉动特性。对不同旋转时刻的内部流动进行分析,发现当流量小于0.75倍额定流量时,叶轮中发生了旋转失速,并且由于隔舌附近逆压梯度较大,当叶轮流道通过隔舌处时会发生“固定失速”的流动现象。对旋转失速条件下蜗壳上的压力脉动进行分析,发现蜗壳隔舌处的压力脉动幅值最高,沿着流动方向依次减小。当旋转失速发生以后,蜗壳上的压力脉动幅值约为非失速工况下的2-3倍,并随着流量减小,压力脉动主频幅值增大。在旋转失速初始阶段,隔舌区“固定失速”对压力脉动的影响较弱,旋转失速的影响占主导,蜗壳上的压力脉动主频为0.5倍叶频;而当流量进一步减小至0.25倍额定流量时,隔舌区的“固定失速”对压力脉动的影响作用增强,削弱了旋转失速的作用,蜗壳上靠近隔舌区的压力脉动主频为叶频,而远离隔舌区的位置受“固定失速”影响较小,旋转失速的影响占主导,主频仍是0.5倍叶频。该研究结果可为离心泵机组运行稳定性提供参考。The impeller-volute interaction around the tongue region in centrifugal pump is always very strong, which usually causes vibration and noise. The tongue region is one of the most critical regions for pressure fluctuation, and in order to reveal the impeller-volute interaction around this region under rotating stall condition, a volute-type centrifugal pump was chosen as the research object to investigate by numerical simulation. A number of reference locations were arranged in the near-tongue region for recording the pressure fluctuations. The entire computational domain including impeller and volute was divided into 4.2 million grid cells, and the time step was set as 2.3 × 10.4 s, totally 360 time steps per impeller revolution.. Corresponding to a Courant number, which was estimated to be smaller than 1.0. Large eddy simulation was applied to simulate the three-dimensional unsteady viscous incompressible flow in the centrifugal pump. The predictions of the numerical model were compared with experimental results of flow-head curve. Good agreement between the simulated and experiment results was obtained. The largest head deviation under different flow rates was 8%, due to the smooth wall assumption during the simulations. Several flow rates were chosen ranging from 100% to 25% of the nominal flow rate for determining the stall point. The internal flow field and pressure fluctuation characteristics at different operating points were obtained. Spectra of pressure pulsation signals were analyzed, and the frequency was normalized by the rotation frequency. The regions with lower values in the pressure field were referred as rotating cells in that the stall was always accompanied by pressure reduction. It has been found that the rotating stall phenomenon occurred as the flow rate was decreased to 0.70 of nominal flow rate. Three stall cells near the entrance of passages could be observed in the pressure distribution. As the flow rate was further decreased, the area of stall cells was larger. Under the rotating stall

关 键 词：离心泵 模型 数值计算 隔舌 旋转失速 压力脉动 大涡模拟 

分 类 号：TH311[机械工程—机械制造及自动化]