基于光谱表示和独立成分分析的混合颜料成分分析方法  

A Composition Analysis Method of Mixed Pigments Based on Spectrum Expression and Independent Component Analysis

作　　者：王功明[1] 刘志勇[2] 

机构地区：[1]清华大学信息艺术与设计系,北京100084 [2]中国科学院计算技术研究所,北京100190

出　　处：《光谱学与光谱分析》2015年第6期1682-1689,共8页Spectroscopy and Spectral Analysis

基　　金：国家重点基础研究发展规划基金项目(2012CB725304);国家自然科学基金项目(61373072);中国博士后科学基金项目(2013M530035)资助

摘　　要：在混合颜料成分分析中,反射光谱法通过计算相似性来判断基本颜料种类,容易受多种基本颜料的影响,造成分析结果不准确。将光谱表示为信号,结合独立成分分析,提出一种基于光谱表示和独立成分分析的混合颜料成分分析方法。首先,采用光谱仪获取混合颜料光谱信息,并将其表示为离散信号的形式;然后,对信号进行独立成分分析,得到基本颜料的光谱信息;随后,通过计算基本颜料光谱与已知颜料光谱的相似性,确定基本颜料种类;最后,逆用Kubelka-Munk混色公式就可以得出基本颜料的比例。我们采用蒙赛尔色卡光谱制作模拟数据,分别进行正常/扰动情况下三种色卡光谱混合信息的成分分析试验,以及从8种色卡光谱中选择若干种混合后的成分分析实验。分离出的光谱形态与已知的原始颜料光谱形态极其相似,平均相似比为97.72%,最大相似比可以达到99.95%,得出的基本颜料比例与混合时的比例基本相同。实验结果表明本方法适用于混合颜料成分分析。Reflectance spectrometry is a common method in composition analysis of mixed pigments.In this method,similarity is used to determine the type of basic pigments that constitute the mixed pigments.But its result may be inaccurate because it is easily influenced by a variety of basic pigments.In this study,a composition analysis method of mixed pigments based on spectrum expression and independent component analysis is proposed,and the composition of mixed pigments can be calculated accurately.First of all,the spectral information of mixed pigments is obtained with spectrometer,and is expressed as the discrete signal.After that,the spectral information of basic pigments is deduced with independent component analysis.Then,the types of basic pigments are determined by calculating the spectrum similarity between the basic pigments and known pigments.Finally,the ratios of basic pigments are obtained by solving the Kubelka-Munk equation system.In addition,the simulated spectrum data of Munsell color card is used to validate this method.The compositions of mixed pigments from three basic pigments are determined under the circumstance of normality and disturbance.And the compositions of mixture from several pigments within the set of eight basic pigments are deduced successfully.The curves of separated pigment spectrums are very similar to the curves of original pigment spectrums.The average similarity is 97.72%,and the maximum one can reach to 99.95%.The calculated ratios of basic pigments close to the original one.It can be seen that this method is suitable for composition analysis of mixed pigments.

关 键 词：颜料 成分分析 光谱 相似性 独立成分分析 蒙赛尔 

分 类 号：TP391[自动化与计算机技术—计算机应用技术]