检索规则说明:AND代表“并且”;OR代表“或者”;NOT代表“不包含”;(注意必须大写,运算符两边需空一格)
检 索 范 例 :范例一: (K=图书馆学 OR K=情报学) AND A=范并思 范例二:J=计算机应用与软件 AND (U=C++ OR U=Basic) NOT M=Visual
作 者:荣亚运 师林丽 张晨[1] 邹丽花[1] 徐颖[1] 朱均均[1,2] 陈丽玮[3] 徐勇[1,2] 勇强[1] 余世袁[1,2]
机构地区:[1]南京林业大学化学工程学院,江苏南京210037 [2]江苏省生物质绿色燃料与化学品重点实验室,江苏南京210037 [3]南京林业大学生物与环境学院,江苏南京210037
出 处:《化工学报》2016年第6期2618-2624,共7页CIESC Journal
基 金:"十二五"国家科技支撑计划项目(2015BAD15B09);江苏省普通高校研究生科研创新计划资助项目(SJLX15_0405);江苏高校优势学科建设工程资助项目~~
摘 要:针对生物乙醇生产过程中木质素降解产物对乙醇发酵的抑制作用,选取6种典型木质素降解产物(香草醛、紫丁香醛、4-羟基苯甲醛、香草酸、紫丁香酸和4-羟基苯甲酸)为研究对象,采用新型脱毒技术——热活化过硫酸盐高级氧化技术氧化脱除,研究了氧化去除条件及其氧化机理。结果表明,以0.1 g·L^(-1)的香草醛为代表物质,其最优氧化条件为:p H 6.0,温度80℃,过硫酸盐浓度1.5 g·L^(-1)。在此优化条件的基础上,研究其他5种典型木质素降解产物的氧化效果。结果表明热活化过硫酸盐氧化木质素降解产物的效果显著,香草醛、4-羟基苯甲醛、香草酸、4-羟基苯甲酸和紫丁香酸的去除率在1 h内均达到100%,紫丁香醛的去除率在2 h内也达到100%。热活化过硫酸盐氧化机理主要是通过投加自由基捕获剂甲醇和叔丁醇间接判定在反应过程中的主要活性物种,结果表明在反应中起到主要作用的活性物种是硫酸根自由基。因此,热活化过硫酸盐可以很好地氧化去除木质素降解产物。Aiming at the effect of lignin-degradation products on ethanol fermentation during the bioethanol production process, six kinds of typical lignin-degradation products(vanillin, syringaldehyde, 4-hydroxybenzaldehyde, vanillic acid, syringic acid and 4-hydroxybenzoic acid) were selected to oxidative removal by a new detoxification technology-advanced oxidation process of heat-activated persulfate. The oxidation removal conditions and its oxidation mechanism were also investigated. The results indicated that the optimal oxidation conditions were p H 6.0, 80℃, and the persulfate concentration of 1.5 g·L^(-1) based on 0.1 g·L^(-1) vanillin. On the basis of the optimized conditions, the oxidation effect of other five of typical lignin-degradation products was studied. The results showed that the effects of oxidation removal were obvious. The removal ratio of vanillin, 4-hydroxybenzaldehyde, vanillic acid and syringic acid reached to 100% within 1 h, while that of syringaldehyde reached to 100% within 2 h. The study of oxidative mechanism was to indirectly decide which the main active species was in the reaction process by the addition of radical scavengers of methanol and t-butanol. The results showed that the main active species were sulfate radicals. Therefore, using heat-activated persulfate is a good way for oxidative removal of the lignin-degradation products.
正在载入数据...
正在载入数据...
正在载入数据...
正在载入数据...
正在载入数据...
正在载入数据...
正在载入数据...
正在链接到云南高校图书馆文献保障联盟下载...
云南高校图书馆联盟文献共享服务平台 版权所有©
您的IP:216.73.216.222