Influence of phosphoric anions on oxygen reduction reaction activity of platinum, and strategies to inhibit phosphoric anion adsorption  

铂催化氧还原反应过程中磷酸的影响及抑制磷酸吸附策略（英文）

作　　者：李玉萍[1,2] 姜鲁华[1] 王素力[1] 孙公权[1] 

机构地区：[1]中国科学院大连化学物理研究所,洁净能源国家实验室(筹),辽宁大连116023 [2]中国科学院大学,北京100049

出　　处：《Chinese Journal of Catalysis》2016年第7期1134-1141,共8页催化学报（英文）

基　　金：supported by the Strategic Priority Research Program of the Chinese Academy of Sciences(XDA09030104);the National Basic Research Program of China(973 Program,2012CB215500);the Key Program of the Chinese Academy of Sciences(KGZD-EW-T08)

摘　　要：Nation-membrane-based proton exchange fuel cells （PEMFCs） typically operate at below 100 ℃. However, H3PO4-doped polybenzimidazole （PBI）-based PEMFCs can operate at 100-200 ℃. This is advantageous because of accelerated reaction rates and enhanced tolerance to poisons such as CO and S02, which can arise from reformed gas or the atmosphere. However, the strong adsorption of phosphoric anions on the Pt surface dramatically decreases the electrocatalytic activity. This study exploits the ＂third-body effect＂, in which a small amount of organic molecules are pre-adsorbed on the Pt surface to inhibit the adsorption of phosphoric anions. Pre-adsorbate species inhibit the ad- sorption of phosphoric anions, but can also partially occlude active sites. Thus, the optimum pre-adsorbate coverage is studied by correlating the oxygen reduction reaction （ORR） activity of Pt with pre-adsorbate coverage on the Pt surface. The influence of the pre-adsorbate molecule length is investigated using the organic amines, butylamine, octylamine, and dodecylamine, in both 0.1 mol/L HCI04 and 0.1 mol/L H3P04. Such amines readily bond to the Pt surface. In aqueous HCI04 electrolyte, the ORR activity of Pt decreases monotonically with increasing pre-adsorbate coverage. In aqueous H3P04 electrolyte, the ORR activity of Pt initially increases and then decreases with in- creasing pre-adsorbate coverage. The maximum ORR activity in H3P04 occurs at a pre-adsorbate coverage of around 20%. The effect of molecular length of the pre-adsorbate is negligible, but its coverage strongly affects the degree to which phosphoric anion adsorption is inhibited. Butylamine adsorbs to Pt at partial active sites, which decreases the electrochemically active surface area. Ad- sorbed butylamine may also modify the electronic structure of the Pt surface. The ORR activity in the phosphoric acid electrolyte remains relatively low, even when using the pre-adsorbate modified Pt/C catalysts. Further development of the catalyst and electrolyte is require与低温(<100 oC)质子交换膜燃料电池相比,磷酸掺杂PBI膜燃料电池可工作于100–200 oC,工作温度的提高有利于提高电极反应动力学速率、增加Pt催化剂对CO等毒物的耐受性,以及简化电池水管理等.然而,磷酸在Pt催化剂表面吸附较强,这将造成Pt一定程度的毒化.基于"第三体效应",即在Pt表面预吸附某些小分子,可在一定程度上抑制磷酸吸附,然而预吸附分子同时也将占据Pt表面部分活性位点,因而Pt的催化性能最终由两个因素决定:磷酸抑制程度和预吸附分子在Pt表面的覆盖度.本文系统考察了Pt表面预吸附分子覆盖度和预吸附分子链长对其催化氧还原反应(ORR)活性的影响.首先,通过控制预吸附了胺类分子的Pt电极的电位,得到表面具有不同覆盖度的Pt电极,考察了0.1 mol/L H_3PO_4电解液中Pt电极对ORR的催化活性随预吸附分子覆盖度的变化规律;为分离磷酸吸附和修饰分子吸附本身对Pt催化活性的影响,对比了0.1 mol/L HClO_4电解液中Pt电极对ORR的催化活性随预吸附分子覆盖度的变化规律.进一步对比研究了不同链长胺分子——正丁胺(BA)、正辛胺(OA)及十二胺(DA)等作为修饰分子对Pt/C催化剂电催化ORR活性的影响.结果表明,随修饰分子在Pt表面覆盖度提高,在0.1 mol/L HClO_4溶液中,由于预吸附分子占据Pt部分活性位,修饰后光滑Pt电极表面的本征活性单调下降;而在0.1 mol/L H_3PO_4中,修饰后光滑Pt电极表面的ORR活性呈现先升高后降低的趋势,当预吸附分子覆盖度约为20%时,其ORR活性最高,为未修饰的光滑Pt电极表面的1.67倍.这表明预吸附分子有效抑制了磷酸的吸附,且当预吸附分子覆盖度约为20%时,预吸附分子对Pt表面的占据与其抑制磷酸吸附的作用达到最佳平衡点.然而,当修饰分子BA,OA和DA在Pt表面覆盖度分别为38.6%,26.1%和26.1%时,Pt/C在0.1 mol/L H_3PO_4中的ORR催化活性接近,分别为未经修饰Pt/C电催�

关 键 词：PlatinumPhosphoric anion poisoningOxygen reduction reactionModified electrodeH3PO4-PBI based fuel cells 

分 类 号：O647.3[理学—物理化学] TM911.4[理学—化学]