考虑颗粒动态尺度影响的泥沙扩散系数模型建立及应用  

Establishment and application of sediment diffusion coefficient model based on influence of particle dynamic scale

作　　者：张自超[1] 陈鑫[1,2] 王福军[1,2] 肖若富[1,2] 

机构地区：[1]中国农业大学水利与土木工程学院,北京100083 [2]北京市供水管网系统安全与节能工程技术研究中心,北京100083

出　　处：《农业工程学报》2016年第22期129-137,共9页Transactions of the Chinese Society of Agricultural Engineering

基　　金：国家自然科学基金资助项目(51321001;51139007);"十二五"国家科技支撑计划资助项目(2015BAD20B01;2012BAD08B03)

摘　　要：在欧拉两相流数值算法中,多采用类比水流涡黏性系数的半经验泥沙扩散系数模型来计算固相体积浓度分布。而在将这一模型用于悬移质固液两相流时,因忽略了颗粒动态尺度对流体湍流强度的影响导致计算精度较低。为了体现这一影响,该文针对悬移质固液两相流,基于类比水流涡黏性系数的半经验模型,以颗粒与含能涡相互作用理论判断颗粒动态尺度和固相体积浓度对流体湍流强度的作用,根据流体湍流平衡流动理论和变量间多元回归分析方法,结合现有试验数据,建立了流体湍流强度变化率与颗粒动态尺度、固相体积浓度的关系式,进而得到了新的泥沙扩散系数的计算模型。通过对圆管中悬移质固液两相流的计算表明,相比于现有泥沙扩散系数模型,该文提出的模型能够体现颗粒动态尺度对泥沙扩散系数的影响,在不同含沙工况下计算得到的固相体积浓度分布与试验结果吻合更好,计算值与试验值的最大相对误差在10%以下,远远小于现有泥沙扩散系数计算模型的最大误差。该文新发展的泥沙扩散系数模型得到的悬移质固液两相流流场的计算精度明显提高,可以用于准确预测悬移质固液两相流流场特性。On the basis of eddy viscosity coefficient theory, the semi-empirical sediment diffusion coefficient models are used widely to calculate the volume concentration of solid phase in the Eulerian two-phase flow simulation. However, the diffusion coefficient models’ accuracy is not enough because the particle dynamic scale influence on the fluid turbulence intensity is ignored when they are applied to suspended load sediment two-phase flow simulation. Thus the fluid turbulence intensity change rate function about particle dynamic scale and solid volume concentration was derived, and a new sediment diffusion coefficient model was established in the present study. The new model was called DC-PDPC model. The function derivation was based on the semi-empirical eddy viscosity coefficient model, the particle-eddy interaction theory about the influence of the particle dynamic scale and solid concentration on the fluid turbulence intensity, the equilibrium flow theory and the multivariate regression theory with data. The suspended load sediment two-phase flow simulations were conducted in a circular tube. The results showed that the maximum relative error of relative solid phase volume concentration between the experiment and the calculated values by NON-DC model was 90%-120% and the error was 10%-25% for Diffusion-in-VOF model under different flow conditions. The simulation precision was low, because change of the sediment diffusion coefficient was not considered due to ignoring the particle dynamic scale and solid phase volume concentration influence on the fluid turbulence intensity. In different cases, the relative error between the experiment and the calculation by the three type models （Diffusion-in-VOF, NON-DC and DC-PDPC） were all high near the wall of the tube. When the particle dynamic scale was less than or equal to 1, the maximum relative error of relative solid phase concentration between the experiment and the calculation by the new DC-PDPC model was less than 10%, which was much less than the value of th

关 键 词：泥沙 颗粒 扩散 固液两相流 悬移质 计算模型 

分 类 号：TH311[机械工程—机械制造及自动化] P333.4[天文地球—水文科学]