腐植酸钠溶液直接磺甲基化制备水煤浆分散剂  

Preparation of coal water slurry dispersant by direct sulfomethylation of sodium humate solution

作　　者：党彤彤 初茉[1] 赵曼[1] 畅志兵[1] 张超[1] 

机构地区：[1]中国矿业大学(北京)化学与环境工程学院,北京100083

出　　处：《煤炭科学技术》2017年第1期221-225,共5页Coal Science and Technology

基　　金：国家重点基础研究发展计划(973计划)资助项目(2014CB744301);国家自然科学基金委员会与神华集团有限责任公司联合资助项目(U1261101)

摘　　要：为制备性能良好、价格低廉的水煤浆分散剂,以霍林河风化褐煤为原料,采用氢氧化钠抽提得到腐植酸钠溶液,对腐植酸钠溶液进行磺甲基化改性制备磺甲基化腐植酸系分散剂(LSHA分散剂)。通过正交试验确定了腐植酸钠溶液直接磺甲基化改性的最佳工艺条件,将此分散剂用于宝日褐煤成型尾料的成浆试验,并与市售萘系分散剂的成浆性能进行比较。结果表明,腐植酸钠溶液直接磺甲基化改性的最佳工艺条件为:亚硫酸钠用量为30%(质量分数,下同),甲醛用量为40%,反应温度为90℃,反应时间为150 min。采用LSHA分散剂制备的水煤浆最高成浆浓度为59.1%,在制浆浓度方面满足水煤浆气化的要求,虽比采用萘系分散剂制备的水煤浆低0.8%,但其稳定性优于萘系分散剂。In order to get good performance and low cost dispersant of coal water slurry, taking Huolinhe weathered lignite as raw materials, sodium humate solution was obtained by extracting lignite with sodium hydroxide, the derived sodium humate solution was sulfomethylated to prepare LSHA dispersant.The optimum processing condition of direct sulfomethylation of sodium humate solution was determined by or- thogonal method, The dispersant was used for the slurry performance test of the after-product of Baori lignite briquette, and compared with the slurry performance of the commercially available naphthalene series dispersant.The results showed that the optimum conditions of the sulfomethylation were obtained as follows：the amount of Na2SO3 was 30%, the amount of HCHO was 40%, the reaction temperature was 90℃,and the reaction time was 150 minutes. The maximum slurry concentration of coal water slurry prepared by LSHA dispersant was 59.1%, which was 0.8% lower than the water coal slurry prepared by naphthalene series, satisfied the requirements of CWS gasification in terms of slurry concentration, and its stability was better than that of naphthalene series.

关 键 词：水煤浆 分散剂 磺甲基化 腐植酸钠溶液 表观黏度 

分 类 号：TQ534.4[化学工程—煤化学工程]