酸析法结晶钴铜矿浸出反萃液中的硫酸铜  

Acid-Precipitation Crystallization of Copper Sulfate from Extraction Solution of Lixivium of Copper-Cobalt Ore

作　　者：肖利[1] 陈玲[1] 付海阔 郭权文 

机构地区：[1]湖南工业大学冶金与材料工程学院,湖南株洲412007 [2]广东佳纳能源科技有限公司,广东清远513000

出　　处：《有色金属（冶炼部分）》2017年第4期6-9,共4页Nonferrous Metals（Extractive Metallurgy)

基　　金：国家自然科学基金资助项目(51208193);湖南工业大学教改课题(2013B06)

摘　　要：采用酸析法结晶钴铜矿浸出反萃液中硫酸铜。结果表明,沉淀3h,结晶率可达第一个最大值80%左右,沉淀5h,结晶率下降至70%左右,此后随着反应时间的增加,结晶率增加;结晶过程随着溶液温度的降低,结晶率上升;结晶过程随着硫酸用量的增加,结晶率先升高后降低;结晶过程随着铜反萃液中Cu^(2+)浓度的增加,结晶率增加。最佳工艺条件为:室温、每100mL铜反萃液中加入30mL硫酸、沉淀3h,结晶率超过80%。结晶母液可循环利用,不会带来环境污染。CuSO4·5H2O crystal was prepared from extraction solution of leaching copper-cobalt ore by acid-precipitation method.The results show that crystallization rate of CuSO4·5H2O reaches first peak value about 80%in three hours and then drops to about 70%in five hours,and crystallization rate rises with increase of reaction time after 5h.Crystallization rate rises with drops of solution temperature during crystallization.Crystallization rate first rises and then drops with increase of dosage of sulfuric acid.Crystallization rate rises with increase of Cu^（2＋） concentration in copper strip liquor.Crystallization rate is80% above under the optimum conditions including room temperature,sulfuric acid dosage of 30 mL for100 mL copper extraction solution,and precipitation time of 3h.Recycled solution after crystallization of copper sulfate can be cyclic utilized without environment pollution.

关 键 词：酸析法 反萃液 硫酸铜 结晶 

分 类 号：TF111.34[冶金工程—冶金物理化学]