超大垢量新建超临界机组化学清洗工艺研究与应用  

Research and application of chemical cleaning technology of supercritical units with large amounts of boiler deposits

作　　者：姚建涛[1] 王德军 刘藏华 张翠伶 YAO Jiantao WANG Dejun LIU Zanghua ZHANG Culling(Xi＇ an Thermal Power Research Institute, Xi＇ an, Shaanxi 710032, China Suizhong Power Plant, Huludao, Liaoning 125205, China Guohua Panshan Power Plant, Tianjin 301900, China)

机构地区：[1]西安热工研究院有限公司,陕西西安710032 [2]绥中发电厂,辽宁葫芦岛125205 [3]国华盘山发电厂,天津301900

出　　处：《清洗世界》2017年第5期1-7,12,共8页Cleaning World

摘　　要：火力发电厂超临界机组锅炉热负荷率很高,受热面内大量的沉积物导致金属壁温升高,将超过金属的许用温度,致使金属材料的力学性能急剧下降,最终引起水冷壁爆管,对机组安全运行危害很大。这种超大垢量的沉积物常规清洗介质难于清洗干净。文中介绍了一种新型清洗工艺的研究过程,及其在600 MW超临界机组超大垢量锅炉化学清洗中的应用。该清洗工艺有效清洗了最大垢量达3 086 g/m^2的新建超临界机组锅炉,清洗结束后检测发现残余垢量仅为12.6 g/m^2。机组重新启动后顺利通过168 h试运,并且一直稳定运行。In the thermal power, the thermal load of supercritical unit boiler is very high, and then large amounts of deposits on the heating surface will result in a much higher temperature rise of metallic tube wall. Once the temperature of the tube wall exceeded the allowable temperature of the metallic material, the mechanical property of the material would sharply reduced, and then tube burst of the water cooled wall could occur, that will se.riously impair the safe operation of units. Very large amounts of deposits cleaning technique are difficult to was introduced clean with normal cleaning media. The development of a new in this paper, which technique was applied to a 600 MW supercritical units with large amounts of boiler deposits.The supercritical units with a deposits amount of 3 086 g/m^2 was effectively cleaned by this clean was measured only 12.6 g/m^2 after the cleaning operation of 168 hours after re-start up ng process,and the amount of remaining The units successfldly passed through and has been stably operated since then. deposits the trial

关 键 词：复合有机酸 锅炉 超临界机组 化学清洗 

分 类 号：TK228[动力工程及工程热物理—动力机械及工程]