某重选尾矿金浮选试验研究  

Experimental Study on Gold Flotation of Gravity Tailings

作　　者：杨玮[1] 董萍 邓忠 YANG Wei;DONG Ping;DENG Zhong(College of Materials and Mineral Resources, Xi＇ an University of Architecture and Technology, Xi＇ an 710055, Shaanxi, China)

机构地区：[1]西安建筑科技大学材料与矿资学院,陕西西安710055

出　　处：《黄金科学技术》2018年第2期203-211,共9页Gold Science and Technology

基　　金：国家自然科学基金项目"氧化铅(PbO)强化难处理高铜金精矿氰化浸出过程的基础研究"(编号:51474169);陕西省工业科技攻关项目"碲化物型难处理金矿金银碲综合回收技术研究"(编号:2016GY-154)联合资助

摘　　要：在工艺矿物学研究的基础上,对某重选尾矿(主要载金矿物为磁黄铁矿和黄铁矿)中的金的综合回收利用开展了选矿试验研究。在磨矿细度为-0.074 mm含量占70%,用NaOH调节矿浆pH=8,捕收剂为异戊基黄药(80 g/t)+丁铵黑药(40 g/t),浮选浓度为33%,粗选时间为3 min的条件下,通过一粗两精三扫的闭路试验流程,可获得金品位为28.40 g/t的浮选精矿,金回收率达到93.47%。通过试验研究发现:在低碱度条件下,采用NaOH作pH调整剂时金的浮选效果明显优于石灰;与丁基黄药相比,使用异戊基黄药作捕收剂,对石灰体系下金回收率的提高效果更好;同时,黄药与黑药的混合使用会起到"协同作用",也能够明显提高金的选别效果。Based on the mineralogy characteristics,the research on the comprehensive recovery and utilization of gold in a gravity separation tailings（the main gold-bearing minerals are pyrrhotite and pyrite）was carried out.Under the condition that the gringding fineness is-0.074 mm content of 70%,NaOH is used to adjust the pulp pH=8,the collector is isoamyl xanthate ＋ ammonium butylate,the flotation concentration is 33%,the coarse selection time is 3 min,the flotation concentrate with gold grade of 28.40 g/t can be obtained through a closed test process of one stage roughing,two stage cleaning and three stage scavenging,and the recovery rate of gold was 93.47%.It is found through experimental research that under the condition of low alkalinity,when NaOH is used as pH regulator,the flotation effect of gold is better than lime;Compared with butyl xanthate,unsing isoamyl xanthate as collector has a better effect on improving the recovery rate of gold under lime syste;At the same time,the combination of xanthate and aerofloat will play a synergistic role,which can also significantly improve the gold separation effect.

关 键 词：重选金尾矿 磁黄铁矿 浮选 调整剂 捕收剂 

分 类 号：TD923.7[矿业工程—选矿]