橡胶促进剂生产废水联合处理工艺探究  

Research on the combined treatment of wastewater from rubber accelerant production

作　　者：张洋 刘勇 王红萍[1,2] Zhang Yang;Liu Yong;Wang Hongping(School of Resources and Environmental Science, Wuhan University, Wuhan 430079, China;Hubei Provincial Collaborative Innovation Center for Water Resources Security, Wuhan 430072, China)

机构地区：[1]武汉大学资源与环境科学学院,湖北武汉430079 [2]水资源安全保障湖北省协同创新中心,湖北武汉430072

出　　处：《工业水处理》2018年第5期54-57,共4页Industrial Water Treatment

基　　金：湖北省环境保护专项资助项目(2011HB12)

摘　　要：对橡胶促进剂生产废水进行分类收集,确定了采用蒸发脱盐-Fe-C微电解-生化法联合的方法处理。试验结果表明,在蒸发脱盐阶段,蒸发量为80%时,出水COD仅为3 112 mg/L,蒸出来的盐中有机物质量分数达40%;在Fe-C微电解阶段,反应时间为4 h,废水p H为3.5,铁碳比为2∶1,COD的去除率可达31.15%,B/C可提高到0.303;生化处理(SBR工艺)阶段,对活性污泥进行培养和驯化32 d后,出水COD稳定在100 mg/L以下,达到国家一级排放标准,活性污泥SOUR也稳定在45 mg O2/(g MLSS·h)左右。The wastewater from rubber accelerant production has been classified and collected. It is ascertained that the combined evaporation desalination-Fe-C micro-electrolysis-biochemical（activated sludge） process should be used for the treatment of this kind of wastewater. The results show that in the evaporation desalination stage,the effluent COD is only 3 112 mg/L,and the mass fraction of organic substances evaporated from salt 40%, when the evaporation capacity is 80%. In the Fe-C micro-electrolysis stage,the removing rate of COD is 31.15%,and B/C is increased to 0.303. Under the following conditions： reaction time is 4 h,pH value 3.5,and Fe/C ratio 2∶1. In the biological（activated sludge） treatment stage,the effluent COD stabilizes at 100 mg/L and reaches the First-level national level of emission standard,the SOUR value of the activated sludge also stabilizes at about 45 mg O2/（g MLSS·h）, after the sludge has been cultivated and domesticated for 32 days.

关 键 词：橡胶促进剂废水 蒸发脱盐 Fe-C微电解 生化处理 

分 类 号：X703.1[环境科学与工程—环境工程]