不同结构滴灌双向流道灌水器抗堵性能对比试验  

Contrast experiment on anti-clogging performance of bidirectional flow channel emitters with different structures in drip irrigation

作　　者：王新端[1] 白丹[1] 宋立勋[2] 郭霖[1] 李嘉露[1] 吴山山 Wang Xinduan;Bai Dan;Song Lixun;Guo Lin;Li Jialu;Wu Shanshan(Institute of Water Resources and Hydroelectric Engineering,Xi’ an University of Technology,Xi’an 710048,China;School of Science,Xi’an Polytechnic University,Xi’ an 710048,China)

机构地区：[1]西安理工大学水利水电学院,西安710048 [2]西安工程大学理学院,西安710048

出　　处：《农业工程学报》2018年第14期78-85,共8页Transactions of the Chinese Society of Agricultural Engineering

基　　金：国家自然科学基金资助项目(41571222;51279156)

摘　　要：该文开展滴灌双向流道抗堵性能研究,以提高灌水器对含沙率较高的地表水源的适应性。试验浑水含沙率为30 g/L,经20次浑水试验,设置3种结构参数不同的双向流道灌水器(1#,2#,3#),并对比迷宫式流道灌水器的水力性能和抗堵性能。结果表明:1#、2#、3#双向流道浑水流量分别为清水流量的77.44%,83.35%,85.43%,而迷宫式流道在12次试验后完全堵塞。双向流道灌水器与迷宫式流道灌水器的水力性能及抗堵性能差异显著,且双向流道的水力性能及抗堵性能均优于迷宫式流道;双向流道水力性能越好,抗堵性能越差;流道形式及结构参数是影响灌水器水力性能及抗堵性能的重要因素。试验结束后,观测流道泥沙沉积情况,发现泥沙沉积程度由前段(进口)到后段(出口)逐渐减少;采用电子显微镜分别获取流道前段、中段和后段沉积泥沙样品扫描图像,利用Image Pro Plus 6.0软件分析沉积泥沙样品的粒径组成,发现沿流道方向,粒径(29)0.03 mm的泥沙颗粒质量分数逐渐减小,粒径(27)0.005 mm的泥沙颗粒质量分数呈先减小后增加的趋势;流道沉积泥沙中粒径(27)0.03 mm的颗粒质量分数占92.23%~97.89%,此粒径范围的泥沙颗粒更易在双向流道内沉积,引起堵塞。The clogging of drip emitters is of great concern to many researchers. A bidirectional flow channel is different from a labyrinth flow channel and it is mainly composed of a structure for dividing water and a structure for blocking water. The main working principle comprises mixing the forward flow and the reverse flow created by the above mentioned structures, and the hydraulic performance is thus enhanced. Although a bidirectional flow channel provides better hydraulic performance, its anti-clogging performance, in particular in cases when muddy water with a high sediment concentration is used, needs to be researched in depth. Hence, periodic intermittent drip irrigation experiments were carried out using muddy water containing sediment particles with different sizes（all less than 0.125 mm）, which were screened by a sieving method, and sediment particles were added to give a concentration of 30 g/L muddy water. To provide a contrast, a type of drip irrigation tube with an embedded labyrinth channel was chosen to compare the anti-clogging performance of the channels. Each test comprised 20 irrigation procedures, each for a period of 30 min, which was the same as the test interval. In the 25 th minute the emitter flow was recorded in real time, and the measurement was continued for 5 min. After the end of each group of treatments, the test specimens were replaced with new specimens and the system was flushed to ensure that no sediment remained. In these experiments, changes in flow rate were measured under a pressure of 50 k Pa. After the end of the trial, the clogged emitters were cut and dried to their natural state, and then the sediment deposited in the bidirectional flow channel was collected; the locations in which sediment was deposited were observed. The structure of the sediment deposits was also observed using an electron microscopy, and the sediment particle size was calculated using Image Pro Plus 6.0 software to analyze the mechanisms that caused clogging by sediment particles with sizes in diffe

关 键 词：泥沙 水力性能 流量 滴灌 双向流道 抗堵性能 

分 类 号：S275.6[农业科学—农业水土工程]