复合保存剂BCT-2/NH_3对鲜天然胶乳保存效果及天然橡胶性能的影响  被引量:7

Influence of Compound Preserving Agent BCT-2/NH_3 on Preservation Effect of Fresh Natural Latex and Properties of Natural Rubber

在线阅读下载全文

作  者:李建伟 栗秀萍[2] 黄红海[1] 于伟强[2] 丁丽[1] 桂红星[1] LI Jianwei;LI Xiuping;HUANG Honghai;YU Weiqiang;DING Li;GUI Hongxing(Institute of Rubber Research,Chinese Academy of Tropical Agricultural Sciences,Danzhou 571737,China;,North University of China,Taiyuan 030051,China)

机构地区:[1]中国热带农业科学院橡胶研究所,海南儋州571737 [2]中北大学化工与环境学院,山西太原030051

出  处:《橡胶工业》2018年第8期877-881,共5页China Rubber Industry

基  金:现代农业产业体系项目(CARS-34-GW9);海南省重大研发计划项目(ZDKJ2016020-01)

摘  要:采用环保型抑菌、杀菌剂BCT-2与氨(NH_3)复配作为鲜天然胶乳的新型复合保存剂,研究其对鲜天然胶乳保存效果、天然橡胶(NR)生胶6项指标、混炼胶硫化特性以及硫化胶物理性能的影响。结果表明:复合保存剂BCT-2/NH_3对鲜天然胶乳的保存效果优于NH_3和NH_3+TMTD/氧化锌,保存144 h后鲜天然胶乳的挥发脂肪酸值在0.05左右,粘度在10mPa·s左右,pH值高于9;相应NR生胶的塑性初值、塑性保持率和门尼粘度均小于NH_3保存试样;随着BCT-2的加入,混炼胶的最小转矩、最大转矩、焦烧时间和正硫化时间与氨保存试样相比均有一定程度的降低和缩短;而复合保存剂BCT-2/NH_3对硫化胶物理性能影响不大。A compound preserving agent for fresh natural latex was prepared by using environmentally friendly antibacterial,bactericide BCT-2 and ammonia(NH3),and the preservation effect and influence of that on the six indexes of NR raw rubber,the curing behavior of NR mix and the physical properties of NR vulcanizate were investigated. The results showed that the preservation effect of BCT-2/NH3 compound preserving agent on fresh natural latex was better than that of NH3 and NH3+TMTD/ZnO. After 144 hours,the volatile fatty acid number was about 0. 05,the viscosity was about 10 mPa·s,and the pH value was above 9. The P0,PRI and Mooney viscosity of NR raw rubber were lower than those of NR preserved with NH3. With the addition of BCT-2,the minimum torque,maximum torque,scorch time and optimum cure time of the compound dropped in some extent compared with NH3 preserved one. BCT-2/NH3 compound preserving agent had little effect on the physical properties of the vulcanizate.

关 键 词:复合保存剂 鲜天然胶乳 天然橡胶 物理性能 

分 类 号:TQ331.2[化学工程—橡胶工业]

 

参考文献:

正在载入数据...

 

二级参考文献:

正在载入数据...

 

耦合文献:

正在载入数据...

 

引证文献:

正在载入数据...

 

二级引证文献:

正在载入数据...

 

同被引文献:

正在载入数据...

 

相关期刊文献:

正在载入数据...

相关的主题
相关的作者对象
相关的机构对象