海绵铁缓解污水厌氧氨氧化反应器中硝酸盐积累的效果  

Sponge iron reliefing nitrate accumulation in wastewater anaerobic ammonium oxide reactor

作　　者：杨世东[1] 陶文鑫[1] 崔鑫鑫 孔龙[1] Yang Shidong;Tao Wenxin;Cui Xinxin;Kong Long(School of Civil Engineering and Architecture,Northeast Electric Power University,Jilin 132012,China)

机构地区：[1]东北电力大学建筑工程学院,吉林132012

出　　处：《农业工程学报》2018年第22期185-190,共6页Transactions of the Chinese Society of Agricultural Engineering

基　　金：吉林省科技厅自然科学基金项目(20150101090JC)

摘　　要：该文旨在通过向厌氧氨氧化反应器中投加海绵铁来减轻厌氧SBR(sequencingbatchreactoractivatedsludge process)反应器中的硝酸盐积累,试验研究了海绵铁与硝酸盐和亚硝酸盐在静态条件下的反应。在静态条件下,部分硝酸盐和亚硝酸盐被海绵铁还原成了氨。对比动态试验表明投加海绵铁可以将SBR出水硝酸盐质量浓度控制在25～30 mg/L左右。相同条件下不投加海绵铁出水硝酸盐质量浓度不断累积,直至超过55 mg/L。这可能是由于铁将硝酸盐还原为亚硝酸盐并与厌氧氨氧化进行了耦合。采用高通量测序发现投加海绵铁的反应器中厌氧氨氧化菌在微生物群落中所占的比例(22.55%)约为不投加反应器(8.85%)的3倍,表明投加海绵铁有利于反应器中厌氧氨氧化(ANAMMOX)菌的生长和厌氧氨氧化反应器的启动。Anaerobic ammonia oxidation(ANAMMOX)is a process in which ammonia,as the electron donor,is oxidized by nitrite.Nitrate is accumulated as the main production in addition to N2 in the solution,causing incomplete removal of total nitrogen in water.Some processes,such as oxic denitrification,anaerobic denitrification or dozing of chemicals,can be used to achieve partial denitrification(reduction of nitrate to nitrite).The reduction of nitrate to nitrite can couple with ANAMMOX process,achieving complete removal of nitrogen.In this paper,sponge iron was added into an ANAMMOX sequencing batch reactor(SBR)to decrease nitrate accumulation.Sponge iron is a kind of special zero-valence iron(ZVI)which has a larger specific surface than that of the normal scrap iron,and is cheaper than nano-ZVI.The sponge iron can react with oxidants,such as oxygen and nitrate,immediately in solution and produce Fe2+or Fe3+.The reactions between sponge iron with nitrite and nitrate were studied in a static state,in which the nitrite and nitrate were reduced into ammonia by sponge iron in solutions.Several factors affecting the reactions between sponge iron with nitrite and nitrate were investigated,such as the dose and particle size of sponge iron,solution pH value and dissolved oxygen(DO).The results showed that small sponge iron particle size and high DO concentration were favorable for nitrite and nitrate removal.Low solution pH value had slight enhancement in nitrate and nitrite removal.In the dynamic experiments,two ANAMMOX SBRs(marked as A and B,both with an effective volume of 2 L)acclimatized with the municipal wastewater plant anaerobic sludge were operated about 20 days,then the reactor B was added with 300 g sponge iron with diameter of 5-8 mm,and the reactor A was used as control.The nitrate concentration in the outlet of reactor B dosed with sponge iron could be kept around 25-30 mg/L,while in reactor A without sponge iron,it could reach 55 mg/L,solving the problem of large quantity of nitrate accumulation.In the reactor A witho

关 键 词：污水 氨氮 硝酸盐 海绵铁 厌氧氨氧化 亚硝酸盐 ASBR 高通量测序 

分 类 号：X703[环境科学与工程—环境工程]