Co-application of energy uncoupling and ultrafiltration in sludge treatment:Evaluations of sludge reduction,supernatant recovery and membrane fouling control  

作　　者：An Ding Yingxue Zhao Zhongsen Yan Langming Bai Haiyang Yang Heng Liang Guibai Li Nanqi Ren 

机构地区：[1]State Key Laboratory of Urban Water Resource and Environment(SKLUWRE),Harbin Institute of Technology,Harbin 150090,China [2]College of Civil Engineering,Fuzhou University,Fuzhou 350116,China

出　　处：《Frontiers of Environmental Science & Engineering》2020年第4期43-52,共10页环境科学与工程前沿（英文）

基　　金：This work was jointly supported by the National Natural Science Foundation of China(No.51608150);Open Project of State Key Laboratory of Urban Water Resource and Environment,Harbin Institute of Technology(No.ES201810-02);Natural Science Foundation of Heilongjiang Province(No.E2017042);China Postdoctoral Science Foundation Grant(Nos.2018T110303 and 2017M610210);Heilongjiang Province Postdoctoral Science Foundation Grant(LBH-TZ14 and LBHZ16070).

摘　　要：Energy uncoupling is often used for sludge reduction because it is easy to operate and does not require a significant amount of extra equipments(i.e.no additional tank required).However,over time the supernatant extracted using this method can deteriorate,ultimately requiring further treatment.The purpose of this study was to determine the effect of using a low-pressure ultrafiltration membrane process for sludge water recovery after the sludge had undergone an energy uncoupling treatment(using 3,3’,4’,5-tetrachlorosalicylanilide(TCS)).Energy uncoupling was found to break apart sludge floe by reducing extracellular polymeric substances(EPS)and adenosine triphosphate(ATP)content.Analysis of supernatant indicated that when energy uncoupling and membrane filtration were coapplied and the TCS dosage was below 30 mg/L,there was no significant deterioration in organic component removal.However,ammonia and phosphate concentrations were found to increase as the concentration of TCS added increased.Additionally,due to low sludge concentrations and EPS contents,addition of 30-60 mg/L TCS during sludge reduction increased the permeate flux(two times higher than the control)and decreased the hydraulic reversible and cake layer resistances.In contrast,high dosage of TCS aggravated membrane fouling by forming compact fouling layers.In general,this study found that the co-application of energy uncoupling and membrane filtration processes represents an effective alternative method for simultaneous sludge reduction and sludge supernatant recovery.

关 键 词：Sludge reduction Energy uncoupling Ultrafiltration membrane Membrane fouling 

分 类 号：X703[环境科学与工程—环境工程]