Experimental investigation on flame stabilization of a kerosene-fueled scramjet combustor with pilot hydrogen  

先锋氢引燃煤油的超燃燃烧室火焰稳定性研究

作　　者：Wen SHI Ye TIAN Wan-zhou ZHANG Wei-xin DENG Fu-yu ZHONG Jia-ling LE 

机构地区：[1]China Aerodynamic Research and Development Center,Mianyang 621000,China

出　　处：《Journal of Zhejiang University-Science A(Applied Physics & Engineering)》2020年第8期663-672,共10页浙江大学学报（英文版）A辑（应用物理与工程）

基　　金：supported by the National Natural Science Foundation of China(No.51706237);the China Aerodynamic Research and Development Center Fundamental and Frontier Technology Research Fund,and the Postdoctoral Research Foundation of China(No.2019M653953)。

摘　　要：Flame stabilization in a kerosene-fueled scramjet combustor was investigated experimentally through Schlieren,flame luminosity,and wall pressure measurement,aiming to obtain better insight into combustion characteristics.Experiments were conducted in a direct-connected supersonic combustion facility with inflow conditions of Mach number 2.0,stagnation pressure 0.82 MPa,and temperature 950 K,simulating the flight condition of Mach number 4.0.Results revealed that kerosene was able to be ignited when the equivalence ratio of pilot hydrogen reached 0.080,but was unsuccessful when the equivalence ratio was 0.040.Once ignited,the intense combustion induced high back pressure forcing the flame to spread into the isolator.The pilot flame invariably appeared in the cavity shear layer and attached to the cavity ramp under different equivalence ratios of pilot hydrogen.With the mass flux of pilot hydrogen increased,the kerosene flame located near the cavity ramp was asymmetrical and unstable since it propagated upstream repeatedly.Therefore,the kerosene could be ignited by a suitable equivalence ratio of continuous pilot hydrogen,potentially accompanied with unstable combustion.目的:1.在模拟飞行马赫数4.0条件下,通过直连实验研究先锋氢当量比对煤油燃料冲压发动机点火及稳焰的影响;2.通过多种非接触光学测量手段研究超燃冲压发动机内燃烧流场的结构变化和火焰建立等动态过程。创新点:1.通过直连实验发现,适量提高先锋氢当量比有利于发动机点火,且先锋氢的存在是发动机稳燃的前提;2.得到了超燃发动机点火及燃烧不稳定特征的流场。方法:1.通过直连实验,得到监测点压力动态变化数据并对其进行分析(图4和5);2.通过光学测量手段,观测流场及火焰动态变化过程(图6~12)。结论:1.当先锋氢当量比为0.080时,煤油燃料超燃冲压发动机成功点火;当先锋氢当量比为0.040时,点火失败;当先锋氢关闭后,超燃冲压发动机熄火。2.煤油火焰主要集中于凹槽后缘斜坡且结构是非对称的;燃烧是不稳定的且伴随着反复的前后移动。

关 键 词：SCRAMJET Flame stabilization Pilot hydrogen KEROSENE Supersonic combustion 

分 类 号：V43[航空宇航科学与技术—航空宇航推进理论与工程]