标准养护条件下活性粉末混凝土性能试验研究  

Experimental Study on the Performance of Reactive Powder Concrete under Standard Curing Conditions

作　　者：黄春霞[1] 杨谦[1] 程兴旺 韩吉禄 HUANG Chunxia;YANG Qian;CHENG Xingwang;HAN Jilu(Shaanxi Polytechnic Institute,Xianyang 712000,China;China Three Gorges Group Co.,Ltd.,Yichang 443133,China)

机构地区：[1]陕西工业职业技术学院,陕西咸阳712000 [2]中国长江三峡集团有限公司,湖北宜昌443133

出　　处：《粉煤灰综合利用》2020年第5期62-65,共4页Fly Ash Comprehensive Utilization

基　　金：陕西省教育厅科研计划项目(19JK0076)。

摘　　要：为了研究标准养护条件下,矿粉、硅灰、钢纤维及水胶比对活性粉末混凝土的工作性能和抗压强度的影响规律,采用单因素对照试验的方法设计了6组配合比,测定其工作性能后,将其制作成试块,在标准养护条件下分别养护7d、14d和28d,测定其抗压强度。试验结果表明:硅灰对活性粉末混凝土的工作性能影响较小,但对抗压强度影响较大;在素活性粉末混凝土中加入适量钢纤维,可改善工作性能,同时提高活性粉末混凝土后期抗压强度;本次试验最终确定的最佳水胶比是0. 22,该组活性粉末混凝土拌合物工作性能良好,7d、14d、28d抗压强度均较高,而且强度保持稳定。In order to study the influence of mineral powder,silica fume,steel fiber and water cement ratio on the working performance and compressive strength of reactive powder concrete under standard curing condition,designed 6 groups of mix proportion by single factor control test.After measuring its working performance,then made into test blocks,the compressive strength was measured after 7 d,14 d and 28 d of standard curing.The test results show that silica fume has little influence on the working performance,but has a great influence on the compressive strength.Adding steel fiber in plain RPC can improve the working performance,and can improve the later compressive strength of RPC;the test results show that the best water binder ratio is 0.22.The working performance is good.The compressive strength of the mixture is high in 7 d,14 d and 28 d,and the compressive strength is stable.

关 键 词：活性粉末混凝土 钢纤维 标准养护 工作性能 

分 类 号：TU528.31[建筑科学—建筑技术科学]