关键层运动监测及岩移5阶段规律——以红庆河煤矿为例  

Key strata movement monitoring during underground coal mining and its 5-stage movement law inversion:A case study in Hongqinghe Mine

作　　者：鞠金峰[1,2] 许家林[3] 刘阳军 马祥 王晓振[6] 王业征 刘乐 谢建林[3] 赵富强 JU Jinfeng;XU Jialin;LIU Yangjun;MA Xiang;WANG Xiaozhen;WANG Yezheng;LIU Le;XIE Jianlin;ZHAO Fuqiang(The National and Local Joint Engineering Laboratory of Internet Application Technology on Mine,China University of Mining and Technology,Xuzhou 221008,China;IoT Perception Mine Research Center,China University of Mining and Technology,Xuzhou 221008,China;State Key Laboratory of Coal Resources and Safe Mining,China University of Mining and Technology,Xuzhou 221116,China;Inner Mongolia Yitai Group Co.,Ltd.,Erdos 017000,China;Inner Mongolia Zhongtai Energy Co.,Ltd.,Erdos 017000,China;School of Mines,China University of Mining and Technology,Xuzhou 221116,China;Cahasu Coal Mine,Guodian&Jiantou Inner Mongolia Energy Investment Co.,Ltd.,Erdos 017000,China)

机构地区：[1]中国矿业大学矿山互联网应用技术国家地方联合工程实验室,江苏徐州221008 [2]中国矿业大学物联网(感知矿山)研究中心,江苏徐州221008 [3]中国矿业大学煤炭资源与安全开采国家重点实验室,江苏徐州221116 [4]内蒙古伊泰集团有限公司,内蒙古鄂尔多斯017000 [5]内蒙古仲泰能源有限公司,内蒙古鄂尔多斯017000 [6]中国矿业大学矿业工程学院,江苏徐州221116 [7]国电建投内蒙古能源有限公司察哈素煤矿,内蒙古鄂尔多斯017000

出　　处：《煤炭学报》2022年第2期611-622,共12页Journal of China Coal Society

基　　金：国家重点研发计划资助项目(2021YFC2902104);国家自然科学基金资助项目(51874175)。

摘　　要：煤炭开采引起的岩移规律一直是采矿领域难解的“黑箱”问题,研究揭示其内部作用机制与演变过程是科学解决采矿工程系列问题的理论基础。基于岩层控制的关键层理论,采用地面钻孔原位监测方法,开展了红庆河煤矿深井特大采高开采条件下覆岩内部移动规律的实测与反演研究。结果表明,覆岩由下向上逐步运移发展的过程呈现5阶段典型分区特征,分别为覆岩超前受压变形阶段、逐层向上断裂运移阶段、覆岩整体快速沉降阶段、上位岩层向下压实阶段以及覆岩整体稳沉阶段。依据5阶段岩移特征,拟合形成了覆岩超前运移的“类指数”岩移边界线,对应井上下超前影响范围分别为地表的340 m以及煤层的99 m;推演得到了关键层逐层向上断裂发展的83°断裂延伸角,对应320 m埋深以下关键层发生超前断裂、以上为滞后断裂。同时,对覆岩“横三区”的具体分布进行了划分;沿走向推进剖面,“类指数”岩移边界线与关键层断裂线之间的区域为超前变形区(煤壁支撑区),对应于岩移阶段1;关键层断裂线之后、直至井上下分别滞后工作面煤壁410和190 m的区域为离层区,对应于岩移阶段2~4;再后方的采空区为重新压实区,对应于岩移阶段5。覆岩关键层运动表现出对地表沉陷的显著控制作用,随着其逐层向上断裂运移,地表沉陷活跃度不断攀升,在主关键层结束其正向回转并开始反向回转时,地表沉陷开始进入峰值状态,且这种峰值的持续对应于覆岩整体的快速沉降;当上位岩层逐步压实下位岩层时,地表沉陷活跃度开始降低;直至主关键层运移稳定,地表沉陷活跃期结束、开始进入衰退期;表明地表沉陷盆地的最终形态直接受控于主关键层的运移状态。The law of strata movement caused by coal mining has always been a difficult“black box”problem in mining engineering research area.To reveal its internal mechanism and evolution process is the theoretical basis for scientifically solving many mining engineering problems.Based on the key stratum(KS)theory of strata control,and using the ground drilling in-situ monitoring method,the actual measurement and inversion study of the internal movement law of the overlying strata are carried out under the conditions of large depth and extra-large mining height in Hongqinghe coal mine.The results show that the process of overburden movement from bottom to top presents five typical stages,including the advanced compression deformation stage of the overburden,the upward breaking movement stage by layer,the rapid settlement stage of the overburden as a whole,the downward pressure of the upper strata and the overall stable settlement stage of the overburden.Based on the five-stage strata movement characteristics,it is considered that the boundary of the overlying strata advanced movement is similar to exponential curve,the leading influence range is 340 m on the surface and 99 m on the coal seam.The angle that the KS break upwards by layer is about 83°,and the KSs below the buried depth of 320 m break advance to the face,and the above break behind the face.Meanwhile,the specific distribution of the“transverse three zones”of the overlying strata is divided.Along the strike profile,the area between the“similar exponential”strata movement boundary line and the KS fracture line is the advanced compression zone(or named coal wall support zone),corresponding to the strata movement stage 1.The area after the break line of the KS until 410 m on the surface and 190 m on the coal seam behind the face is the separation zone,which corresponds to the strata movement stage 2 to stage 4.The goaf at the rear is the re-compaction zone,corresponding to stage 5 of strata movement.The movement of the KS exhibits significant control o

关 键 词：岩层移动 钻孔原位监测 关键层 分区运移 岩移边界 地表沉降 

分 类 号：TD325[矿业工程—矿井建设]