混凝-微波强化Fenton法处理PVA废水  

PVA Wastewater Treatment Based on Coagulation and Enhanced Fenton by Microwave

作　　者：李亚峰[1] 白靖铭 刘文卿 LI Yafeng;BAI Jingming;LIU Wenqing(School of Municipal and Environmental Engineering,Shenyang Jianzhu University,Shenyang,China,110168;East China Architectural Design&Research Institute Co.Ltd.,Shanghai,China,200070)

机构地区：[1]沈阳建筑大学市政与环境工程学院,辽宁沈阳110168 [2]华东建筑设计研究院有限公司华东都市建筑设计研究总院,上海200070

出　　处：《沈阳建筑大学学报（自然科学版）》2022年第1期179-185,共7页Journal of Shenyang Jianzhu University：Natural Science

基　　金：水体污染控制与治理科技重大专项(2018ZX07601001)。

摘　　要：目的研究混凝与微波强化Fenton体系降解PVA废水的去除效果。方法采用混凝除去一部分PVA废水,确定混凝条件。经混凝处理后的废水,采用微波强化Fenton法进一步处理,改变各种影响因素后观察PVA废水的降解程度,比较得出最佳影响因素。结果混凝预处理的PVA废水,pH为8,PAC的投加量为50 mL/L,PAM投加量为4 mL/L,以250 r/min搅拌30 s,再以50 r/min搅拌15 min,COD去除率可以达到33.17%。微波强化Fenton法处理混凝后的PVA废水,H_(2)O_(2)投加量为14 mL/L,FeSO_(4)·7H_(2)O投加量为30 g/L,微波的辐射功率为400 W,微波的辐射时间为5 min,pH值为3时,COD去除率为89.54%,COD质量浓度从3000 mg/L左右降低至300 mg/L左右。通过正交试验得出,对处理效果的影响由强到弱依次为:辐射时间、Fe^(2+)、H_(2)O_(2)、pH。结论混凝-微波强化Fenton法药剂投加量低,可提高COD的去除率,能有效地处理PVA废水。The treatment efficiency of PVA wastewater by coagulation and enhanced Fenton with microwave was studied.Coagulation conditions was determined by coagulation test.The wastewater after coagulation was further treated by microwave enhanced Fenton method,and the treatment effect of different conditions on PVA wastewater was analyzed to determine the best experimental conditions.In coagulation pretreatment test of PVA wastewater,under pH8,PAC dosage 50 mL/L,PAM dosage 4 mL/L,stir at 250 r/min for 30 s,then at 50 r/min for 15 min,COD removal rates are 33.17%.In microwave enhanced Fenton test of PVA wastewater after coagulation,when the dosage of H_(2)O_(2)14 mL/L,the dosage of FeSO_(4)·7 H_(2)O 30 g/L,the irradiation power of microwave 400 W,the irradiation time of microwave 5 min,pH 3,the removal rate of COD is 89.54%and the COD is reduced from about 3000 mg/L to about 300 mg/L.The order of the influence on the treatment effect is:radiation time>Fe^(2+)>H_(2)O_(2)>pH.The coagulation-microwave enhanced Fenton can effectively treat PVA wastewater,the dosage of the system agent is low,and the COD removal rate can also be improved.

关 键 词：PVA废水 混凝 FENTON 微波 

分 类 号：TU99[建筑科学—市政工程] X703[环境科学与工程—环境工程]