铁泥基催化剂非均相Fenton深度处理造纸废水  

Advanced Treatment of Papermaking Wastewater by Heterogeneous Fenton Process with Iron Sludge-based Catalyst

作　　者：罗清 薛伟 张安龙 宗晓宁 井天昊 宋刚 LUO Qing;XUE Wei;ZHANG Anlong;ZONG Xiaoning;JING Tianhao;SONG Gang(College of Bioresources Chemical and Materials Engineering,National Demonstration Center for Experimental Light Chemistry Engineering Education,Shaanxi University of Science&Technology,Xi’an,Shaanxi Province,710021;School of Environmental Science and Engineering,Shaanxi University of Science&Technology,Xi’an,Shaanxi Province,710021;Ningxia Brothers Packaging Materials Co.,Ltd.,Wuzhong,Ningxia Hui Autonomous Region,751102)

机构地区：[1]陕西科技大学轻工科学与工程学院,轻化工程国家级实验教学示范中心,陕西西安710021 [2]陕西科技大学环境科学与工程学院,陕西西安710021 [3]宁夏兄弟包装材料有限公司,宁夏吴忠751102

出　　处：《中国造纸》2022年第5期1-7,共7页China Pulp & Paper

摘　　要：以Fenton氧化处理造纸废水产生的污泥为原料,复配粉煤灰、煤泥、羧甲基纤维素钠,采用高温热解的方法制备铁泥基催化剂。以废纸造纸二沉池出水为目标污染物,并以COD_(Cr)去除率和色度去除率作为评价指标,研究了非均相Fenton深度处理过程中铁泥基催化剂对废水的处理效果。结果表明,铁泥基催化剂的比表面积为230 m^(2)/g;当反应体系初始pH值为2.5、催化剂投加量15 g/L、m(COD_(Cr))∶m(H_(2)O_(2))=1∶1.5、反应时间100 min时,COD_(Cr)去除率为66.7%,色度去除率高于80%,污泥产量比均相Fenton降低了91%~94%。Iron sludge-based catalysts were prepared via high temperature pyrolysis,with sludge from papermaking wastewater treated by Fenton oxidation as raw material,and compounded with fly ash,coal sludge and sodium carboxymethyl cellulose.The effects of iron sludge-based catalyst on the treatment of wastewater during heterogeneous Fenton advanced treatment were studied with effluent of secondary sedi‐mentation tank of waste papermaking as the target pollutant,and COD_(Cr) removal rate and color removal rate as the evaluation indexes.The results showed that the specific surface area of iron sludge-based catalyst was 230 m^(2)/g.When the initial pH value of the reaction system was 2.5,the dosage of catalyst was 15 g/L,m(COD_(Cr))∶m(H_(2)O_(2))was 1∶1.5,and the reaction time was 100 min,the removal rate of COD_(Cr) was 66.7%,the removal rate of color was higher than 80%,and the sludge yield was 91%~94%lower than that of homogeneous Fenton.

关 键 词：FENTON处理 污泥 铁泥基催化剂 非均相FENTON 造纸废水 

分 类 号：X793[环境科学与工程—环境工程]