膜蒸馏处理环控生保系统中尿液的研究  

Study on the urine treatment with membrane distillation for application in environmental control and life support system

作　　者：高瑞 康赛 苑宏英 张良长[3] 艾为党[3] 员建 郑利兵[2] 魏源送[2] GAO Rui;KANG Sai;YUAN Hongying;ZHANG Liangchang;AI Weidang;YUAN Jian;ZHENG Libing;WEI Yuansong(College of Environmental and Municipal Engineering,Tianjin Chengjian University,Tianjin 300384,China;Laboratory of Water Pollution Control Technology,Research Center for Eco-Environmental Sciences,Chinese Academy of Sciences,Beijing 100085;National Key Laboratory of Human Factors Engineering,China Astronaut Research and Training Center,Beijing 100094,China)

机构地区：[1]天津城建大学,环境与市政工程学院,天津300384 [2]中国科学院生态环境研究中心,水污染控制实验室,北京100085 [3]中国航天员科研训练中心,人因工程重点实验室,北京100094

出　　处：《膜科学与技术》2023年第2期128-137,149,共11页Membrane Science and Technology

基　　金：国家自然科学基金青年基金资助项目(51908539);人因工程国家重点实验室2019预研基金资助项目(6142222190715)。

摘　　要：尿液的处理与水回收是目前环控生保系统(ECLSS)研究的难点和重点.本文采用膜蒸馏(MD)进行尿液处理,考察膜材料、进料液温度及不同预处理方式对尿液MD处理过程效能的影响.研究发现PTFE膜具有较好的MD性能,温差从15℃提升到45℃时,通量由3.35提高到16.54 kg/(m^(2)·h).尿液处理过程中溶解性有机物(DOM)主要包括酪氨酸类蛋白(C1)、色氨酸类蛋白(C2)及富里酸类物质(C3),C1占比60%以上,C/N比较低.MD过程出现了微生物污染,进一步提升了C2的占比,降低了DOM腐殖化程度.陶瓷膜预处理可截留大分子物质以减缓膜污染;酸化可稳定尿液性质,显著减缓有机-无机-微生物污染,初始通量提高10%,长期稳定性显著提高.本研究为尿液处理与回收提供了一种有效的方案,可支撑ECLSS废水的处理与回用.The treatment and water recovery of urine is a key but one tough issue in environmental controlled and life support systems(ECLSS).Membrane distillation(MD)was applied for urine treatment in this work,and the effect of membrane materials,feed water temperature,and different pretreatment methods on the efficiency of urine treatment were investigated.PTFE membrane was found the optimal membrane for MD,and the flux increased from 3.35 to 16.54 kg/(m^(2)·h)when the temperature difference was increased from 15℃to 45℃.Three key dissolved organic matters(DOM)were identified in the urine treatment processes,which were tyrosine-like(C1),tryptophan-like(C2),and humic substance(C3).Among them,C2 had a dominant role with a proportion significantly higher than 60%.Thus,the C/N ratio is low,with a significant endogenic property.Biofouling happened during MD,which further increase the C2 proportion and the humification degree was significantly decreased.Ceramic membrane showed good performance for rejecting macromolecules,and the fouling can be alleviated.Acidification promotes urine stabilization,thus the inorganic fouling,organic fouling,and biofouling were significantly controlled with a 10%increase in initial flux.And the long-term stability can be obtained for the reduced fouling and wetting.This study provides an effective solution for urine treatment and recovery,which can support wastewater treatment and recyclling in ECLSS.

关 键 词：尿液 膜蒸馏 陶瓷膜 环控生保系统 膜污染. 

分 类 号：TQ028[化学工程] X703[环境科学与工程—环境工程]