黄铜矿浮选体系晶态/无定形二氧化硅的流变特性与夹带行为  

Rheological properties and entrainment behavior of quartz/amorphous silica in chalcopyrite flotation

作　　者：王磊[1] 李孟乐 邹玉超 廖寅飞[1] 马子龙[1] 桂夏辉[1] WANG Lei;LI Meng-le;ZOU Yu-chao;LIAO Yin-fei;MA Zi-long;GUI Xia-hui(National Engineering Research Centre of Coal Preparation and Purification,China University of Mining and Technology,Xuzhou 221116,China;School of Chemical Engineering and Technology,China University of Mining and Technology,Xuzhou 221116,China)

机构地区：[1]中国矿业大学国家煤加工与洁净化工程技术研究中心,徐州221116 [2]中国矿业大学化工学院,徐州221116

出　　处：《工程科学学报》2023年第8期1272-1280,共9页Chinese Journal of Engineering

基　　金：国家自然科学基金资助项目(51804307)。

摘　　要：硅酸盐类脉石夹带是制约贫杂难选矿高效浮选分离的难题之一.借助分批浮选试验、流变学测试、冷冻扫描电镜测试、颗粒沉降试验,探究了黄铜矿浮选体系晶态/无定形二氧化硅的流变特性与夹带行为.结果显示,随着脉石中无定形二氧化硅含量的增加,矿浆表观黏度呈指数型增大,黄铜矿回收率持续降低,脉石回收率先升高后降低.脉石回收率发生变化是脉石夹带率、水回收率共同作用的结果:在黏度低增长区,脉石夹带率上移对脉石回收率升高起主导作用,而在黏度中、高增长区,水回收率减少是脉石回收率由升转降的主要原因.总脉石夹带率和各粒级脉石夹带率均随无定形二氧化硅含量增加而升高,且各粒级脉石夹带率呈现出明显差异性,细粒脉石夹带率增幅最大.冷冻扫描电镜与沉降试验表明,无定形二氧化硅与石英颗粒形成了聚集体结构,导致矿浆体系黏度增大,因而脉石颗粒沉降减缓、泡沫排液“洗涤”脉石作用弱化,单位泡沫水中的脉石质量增大,脉石夹带率升高.Owing to the global consumption of high-grade ores,large amounts of low-grade and complex ores are being processed nowadays.The entrainment of gangue minerals in the ores,especially silicate gangue minerals,has become a nonignorable issue that can significantly influence mineral flotation performance.Amorphous silica has been reported to exist widely in various ore deposits,but how it affects mineral flotation remains poorly understood.This study investigated the rheological properties and entrainment behaviors of quartz/amorphous silica gangue in copper flotation through batch flotation tests,rheology measurements,cryo-SEM analysis,and particle settlement tests.Results indicate an exponential increase in the pulp viscosity as the amorphous silica content in the gangue increased.These also led to distinct recoveries of chalcopyrite and gangue minerals in flotation:the chalcopyrite recovery kept decreasing,whereas the entrainment recovery of gangue minerals increased initially and then decreased.The change in the entrained gangue recovery was found to be a consequence of the reduced water recovery and the increased degree of entrainment for the gangue.In a range wherein the viscosity growth was low,the increased degree of entrainment for the gangue prevailed over the decreased water recovery, ultimately leading to an increase in the gangue recovery. However, when the pulp viscosity drastically increased, the decreasedwater recovery was found to be dominant in changing the gangue recovery, and thus the gangue recovery decreased. Further, the effectof amorphous silica on the degree of entrainment for the gangue was investigated on a size-by-size basis. A great difference was found inthe degree of entrainment for the gangue mineral particles of the same size fraction. However, fine gangue mineral particles experiencedthe greatest increase in their entrainment degree. Therefore, the degree of entrainment for the gangue was size-dependent and subject tothe presence of amorphous silica. The results of cryo-SEM and settl

关 键 词：浮选 夹带 无定形二氧化硅 流变性 夹带率 

分 类 号：TD952[矿业工程—选矿]