考虑动态刚度的电磁阻尼器-轴承-转子减振研究  

Vibration Reduction of Bearing-Rotor with Electromagnetic Damper Considering Dynamic Stiffness

作　　者：肖玲[1] 周游 赵晨曦 郑善栋 程文杰[1] 冯圣 XIAO Ling;ZHOU You;ZHAO Chenxi;ZHENG Shandong;CHENG Wenjie;FENG Sheng(College of Science,Xi’an University of Science and Technology,Xi’an 710054,China;School of Mechanical Engineering,Xi’an Jiaotong University,Xi’an 710049,China)

机构地区：[1]西安科技大学理学院,陕西西安710054 [2]西安交通大学机械学院,陕西西安710049

出　　处：《西南交通大学学报》2023年第4期957-964,共8页Journal of Southwest Jiaotong University

基　　金：国家自然科学基金(52275271);陕西省自然科学基金(2022JM-194)。

摘　　要：为了有效抑制转子系统的不平衡振动,本文提出将考虑动态刚度的电磁阻尼器应用于转子系统中.首先,建立转子系统运动方程并对其进行无量纲化;其次,基于等效磁路法,建立了考虑涡流效应的电磁阻尼器模型,分析了涡流效应对电磁阻尼器刚度的影响,并采用非线性动态自适应惯性权重的PSO算法对电磁阻尼器的PID(比例、积分、微分)3个控制参数进行优化;最后,对转子的动力学特性进行了分析.研究结果表明:在涡流效应的影响下,电磁阻尼器的刚度是动态变化的,当转速为100 kHz时,理论上位移刚度和电流刚度分别下降了10.0%、6.6%;通过非线性动态自适应惯性权重的PSO算法优化得到的PID参数响应快,超调量小,能够在0.1 s内迅速地将圆盘的偏离量调至0,具有良好的控制效果;相比于静态刚度,考虑动态刚度后,圆盘的振幅有所增大,当转速为4782 Hz时,圆盘的振幅增大了5.33%;偏心距增大会导致圆盘的振幅增大,当转速超过242 Hz时,圆盘振幅增大的幅度与圆盘偏心距增大的幅度几乎成正比.In order to suppress the unbalance vibration of the rotor system effectively,the electromagnetic damper considering dynamic stiffness was applied to the rotor system in this paper.Firstly,the motion equations of the rotor system were established and nondimensionalized;secondly,based on the equivalent magnetic circuit method,the electromagnetic damper model considering the eddy-current effect was established,and the influence of the eddy-current effect on the stiffness of the electromagnetic damper was analyzed.The particle swarm optimization(PSO)algorithm with nonlinear dynamic adaptive inertia weight was used to optimize the three control parameters of the proportion integration differentiation(PID)of the electromagnetic damper;finally,the dynamic characteristics of the rotor were analyzed.The results indicate that under the influence of the eddycurrent effect,the stiffness of the electromagnetic damper dynamically changes.When the speed is 100 kHz,the displacement stiffness and current stiffness decrease by 10.0%and 6.6%respectively;the PID parameters optimized by the PSO algorithm with nonlinear dynamic adaptive inertia weight have great control effects,such as fast response and small overshoot,and they can quickly adjust the deviation of the disk to 0 within 0.1 seconds;compared with static stiffness,the amplitude of the disk increases slightly after considering dynamic stiffness.When the speed is 4782 Hz,the amplitude of the disk increases by 5.33%;the increase in eccentricity will lead to an increase in the amplitude of the disk.When the speed exceeds 242 Hz,the amplitude of the disk increases almost proportionally to that of the disk eccentricity.

关 键 词：电磁阻尼器 磁路 涡流 动态刚度 

分 类 号：TH133.3[机械工程—机械制造及自动化]