ZnO@PAN柔性复合纳米纤维膜的制备及压电特性  

Preparation and Piezoelectric Properties of ZnO@PAN Flexible Composite Nanofiber Membranes

作　　者：张瑞[1] 李银辉[1] 高飞[1] 梁建国 李朋伟[1] Zhang Rui;Li Yinhui;Gao Fei;Liang Jianguo;Li Pengwei(Nano Energy and Device Research Centre,School of Electronic Information and Optical Engineering,Taiyuan University of Technology,Taiyuan 030024,China)

机构地区：[1]太原理工大学电子信息与光学工程学院纳米能源与器件研究中心,太原030024

出　　处：《微纳电子技术》2024年第6期45-53,共9页Micronanoelectronic Technology

基　　金：国家自然科学基金(61901293,52075361);山西省重点研发项目(201903D421030);山西省科技重大专项(20201102003);山西省青年科学基金(20210302124046);吕梁市校地合作重点研发专项(2022XDHZ08)。

摘　　要：采用静电纺丝技术,通过两步低温水热法制备了ZnO@聚丙烯腈(PAN)柔性复合纳米纤维膜。研究了静电纺丝电压和滚筒转速对ZnO@PAN柔性复合纳米纤维膜压电和铁电性能的影响。研究结果表明,当静电纺丝电压为20 kV、滚筒速度为1000 r/min时,ZnO@PAN柔性复合纳米纤维膜的输出性能达到最佳,输出开路电压可达到5.5 V,短路电流可达到0.61μA,剩余极化强度可达到0.43μC/cm^(2)。在外部负载电阻为13 MΩ时,柔性复合纳米纤维膜达到最大输出功率0.63μW。经过5000次循环敲击测试,所制备的ZnO@PAN柔性复合纳米纤维膜输出性能保持稳定。通过ZnO@PAN柔性复合纳米纤维膜可实时监测握力器微握、半握、全握三种不同的状态,在自供电柔性压力传感器领域有着广阔的应用前景。ZnO@polyacrylonitrile(PAN)flexible composite nanofiber membranes were prepared by a two-step low-temperature hydrothermal method using electrostatic spinning technology.The effects of electrostatic spinning voltage and drum speed on the piezoelectric and ferroelectric properties of ZnO@PAN flexible composite nanofiber membranes were investigated.The results show that when the electrostatic spinning voltage is 20 kV and the drum speed is 1000 r/min,the output performance of ZnO@PAN flexible composite nanofiber membrane reaches the optimum that the output open-circuit voltage up to 5.5 V,the short-circuit current up to 0.61μA,and the residual polarisation strength up to 0.43μC/cm^(2).The maximum output power of the flexible composite nanofiber membrane is 0.63μW at an external load resistance of 13 MΩ.The output performance of the prepared ZnO@PAN flexible composite nanofiber membrane remains stable after 5000 cyclic hammering tests.The ZnO@PAN flexible composite nanofiber membrane can be used to monitor three different states of the gripping device:microgrip,half-grip and full-grip in real time,which has a broad application prospect in the field of self-powered flexible pressure sensors.

关 键 词：ZnO@聚丙烯腈(PAN) 柔性复合纳米纤维膜 静电纺丝技术 压力传感器 柔性材料 

分 类 号：TM919[电气工程—电力电子与电力传动] TB33[一般工业技术—材料科学与工程] TB34