EACD技术处理煤矿酸性废水硫酸根的研究  

Study on treatment of sulfate radical in acid wastewater from coal mine by EACD technology

作　　者：于明丽 张伦秋[1] 田葳[1] 杨朝粉 刘欢 田岳尧 杜胜男 宋洋 YU Mingli;ZHANG Lunqiu;TIAN Wei;YANG Chaofen;LIU Huan;TIAN Yuerao;DU Shengnan;SONG Yang(School of Civil Engineering,Liaoning Petrochemical University,Fushun 113000,China;Ningbo Institute of Technology,Ningbo 315211,China;Liaoning Shiyu Environmental Protection Technology Co.,Ltd.,Shenyang 110000,China)

机构地区：[1]辽宁石油化工大学土木工程学院,辽宁抚顺113000 [2]宁波工程学院,浙江宁波315211 [3]辽宁省实誉环保科技有限公司,辽宁沈阳110000

出　　处：《应用化工》2024年第9期2100-2104,2108,共6页Applied Chemical Industry

基　　金：2020年辽宁省教育厅科学研究经费项目(L2020027)。

摘　　要：采用·OH清除剂优化接地极雾化电晕放电(EACD)技术处理煤矿酸性废水,利用响应面法研究了放电电压、放电时间和硫酸根与苯酚的浓度比对硫酸根降解率的影响。结果表明,各因素显著性顺序为:硫酸根与苯酚的浓度比>放电电压>放电时间,放电电压、硫酸根与苯酚的浓度比的交互作用对硫酸根去除率影响显著。优化条件为:放电电压12 kV、放电时间66 min、硫酸根与苯酚的浓度比0.9时,对应的硫酸根去除率为76.55%,与预测值仅有0.55%的误差。实验结果与模型数值高度吻合,证实了该回归模型的准确性。Acidic wastewater from coal mine was treated by optimized grounding electrode atomization corona discharge(EACD)technology with•OH scavenger.The effects of discharge voltage,discharge time and concentration ratio of sulfate to phenol on the degradation rate of sulfate were studied by using the response surface method.The result showed that the order of significance of each factor was as follows:concentration ratio of sulfate to phenol>discharge voltage>discharge time,and the interaction of discharge voltage and concentration ratio of sulfate to phenol had a significant effect on the removal rate of sulfate.The optimized conditions were:the discharge voltage of 12 kV,the discharge time of 66 min,the concentration ratio of sulfate to phenol of 0.9,corresponding the sulfate removal rate was 76.55%and the error compared with the predicted value was only 0.55%.The experimental results are highly consistent with the model values,which confirms the accuracy of the regression model.

关 键 词：接地极雾化电晕放电(EACD) 硫酸根 煤矿酸性废水 ·OH清除剂 响应面法 

分 类 号：TQ93[化学工程] TQ9TQ31