检索规则说明:AND代表“并且”;OR代表“或者”;NOT代表“不包含”;(注意必须大写,运算符两边需空一格)
检 索 范 例 :范例一: (K=图书馆学 OR K=情报学) AND A=范并思 范例二:J=计算机应用与软件 AND (U=C++ OR U=Basic) NOT M=Visual
作 者:张祥斌 任伟才[1] 王凤春[1] 李艺萌 刘长琳 王金花[1] 宋阳 刘云龙[1] ZHANG Xiangbin;REN Weicai;WANG Fengchun;LI Yimeng;LIU Changlin;WANG jinhua;SONG Yang;LIU Yunlong(Northeast Light Alloy Co.,Ltd.,Harbin 150060,China)
机构地区:[1]东北轻合金有限责任公司,黑龙江哈尔滨150060
出 处:《轻合金加工技术》2024年第6期6-12,共7页Light Alloy Fabrication Technology
摘 要:研究了不同单级均匀化退火制度对高合金化Al-8Zn-2Mg-2Cu合金组织的影响。通过对第二相及共晶组织的演化规律分析获得了合金较为理想的单级均匀化退火制度。组织分析发现,Al-8Zn-2Mg-2Cu合金中第二相主要为片层状的T(AlZnMgCu)相,以及片层间与T(AlZnMgCu)相共生的Al_(2)CuMg相,过烧温度为476℃。在465、470、475℃三种温度下开展的单级均匀化退火处理研究结果表明,在过烧温度下进行单级均匀化退火处理很难将共晶组织完全消除。本研究确定的较为理想的均匀化退火制度为475℃96 h,在此制度下的第二相残留数量最少、形貌圆滑,且共晶组织体积分数最低为0.5%。High-alloying Al-8Zn-2Mg-2Cu aluminum alloy was investigated with different single-stage homogenizing annealing systems.An ideal system was obtained by analyzing the evolution laws of the second phase and eutectic structure.Structure analysis show that the second phase is mainly the layered T(AlZnMgCu)phase and the Al_(2)CuMg phase coexisting with T(AlZnMgCu)between the layers.The overburning temperature is 476℃.Different single-stage homogenizing annealing were conducted at 465℃,470℃,and 475℃,respectively.The results indicate that it is difficult to completely eliminate the eutectic structure at the overburning temperature.The resulted ideal system is 475℃96 h,in which the residual amount of the second phase is minimum,the morphology is smooth,and the volume fraction of the eutectic structure is the lowest at 0.5%.
关 键 词:单级均匀化退火 高合金化 Al-8Zn-2Mg-2Cu合金 第二相 共晶组织
分 类 号:TG146.21[一般工业技术—材料科学与工程]
正在载入数据...
正在载入数据...
正在载入数据...
正在载入数据...
正在载入数据...
正在载入数据...
正在载入数据...
正在链接到云南高校图书馆文献保障联盟下载...
云南高校图书馆联盟文献共享服务平台 版权所有©
您的IP:216.73.216.38