二胺类药剂对霓石絮凝沉降性能的影响及吸附机理研究  

Study on the influence of diamine agents on the flocculation settling performance of aegirite and their adsorption mechanisms

作　　者：胡义明 曹阳 杨诚 黄洋 高翔鹏 李明阳 Yiming HU;Yang CAO;Cheng YANG;Yang HUANG;Xiangpeng GAO;Mingyang LI(School of Metallurgical Engineering,Anhui University of echnology,Ma'anshan,Anhui 243032,China)

机构地区：[1]安徽工业大学冶金工程学院,安徽马鞍山243032

出　　处：《过程工程学报》2024年第11期1318-1325,共8页The Chinese Journal of Process Engineering

基　　金：安徽省高等学校科学研究重点项目(编号:2022AH050305);安徽省优秀青年教师培育项目(编号:YQZD2023027);金属矿山安全与健康国家重点实验室开放课题(编号:2022-JSKSSYS-07)。

摘　　要：霓石是一种常与铁矿石伴生的脉石矿物,由于其自身硬度较低,在磨矿过程中极易泥化,对铁尾矿絮凝造成不利影响。本研究通过絮凝沉降实验探索了6种分子两端均为氨基的二胺类药剂对霓石絮凝性能的影响,并通过对比实验筛选出了絮凝效果最佳的絮凝剂1,8-辛二胺(ODM)。絮凝沉降实验结果表明,在pH=6、ODM质量浓度为0.1wt%时ODM对霓石的絮凝效果最佳,此时霓石可在60s内沉降完全,絮凝沉降速度约是自由沉降的4倍。此外,通过Zeta电位测量、红外光谱分析(FTIR)和X射线光电子能谱测试(XPS)等表征得出ODM在霓石表面的吸附机理。实验结果表明,ODM主要通过静电吸附和氢键吸附作用于霓石表面,且静电吸附在吸附过程中占据主导作用。Aegirite is a gangue mineral often associated with iron ore.Due to its low hardness,it is easier to be crushed and argillated than iron ore in the grinding process.The argillated fine aegirite further increases the difficulty of iron tailings treatment.In this study,the effects of 6 kinds of diamines with different molecular chain lengths and both ends were amino on the flocculation performance of aegirite were explored through flocculation sedimentation test,and 1,8-octamethylene diamine(ODM)with the best flocculation effect was selected through free sedimentation test,flocculant type test,pH test and flocculant concentration test in sequence.The adsorption mechanism of ODM on the surface of fluorite was investigated using Zeta potential measurements,Fouriertransform infrared spectroscopy(FTIR),and X-ray photoelectron spectroscopy(XPS)analysis.The results of flocculation and sedimentation test showed that the best flocculation effect of ODM on aegirite was achieved when pH=6 and ODM concentration was 0.1wt%.In this case,aegirite settles completely within 60 s,and the rate of flocculation settlement is about 4 times that of free settlement.In addition,the Zeta potential of aegirite before and after the flocculation reaction was measured by the mechanism test.After adding the flocculant,the zero potential point of aegirite moved from 4.56 to 6.56,indicating that the interaction between the flocculant and the surface of aegirite was obvious.The adsorption behavior of the flocculant on the surface of aegirite was verified by FTIR analysis,and the functional groups belonging to the flocculant were adsorbed on the surface of aegirite.The adsorption mechanism was verified by XPS.It was found that the high resolution spectra of C 1s and N 1s after the treatment of the agent showed obvious new peaks,which further indicated that the agent was adsorbed on the surface of aegirite,and the binding energy of the upper peak of the Fe 2p spectrum was shifted by 0.1 eV,indicating that the adsorption behavior was non-chemisorption

关 键 词：霓石 絮凝 二胺类药剂 氢键吸附 静电吸附 

分 类 号：TQ424[化学工程] TD951[矿业工程—选矿]