硫酸亚铁沉淀法处理含钒废水  

Precipitating treatment of vanadium contained waste water by using ferrous sulfate

作　　者：关洪亮[1] 操艳兰[1] 顾逸雅[1] 李彩霞[1] 王杏林[1] 何东升[1] 余训民[1] 

机构地区：[1]武汉工程大学环境与城市建设学院,湖北武汉430074

出　　处：《武汉工程大学学报》2012年第12期25-27,31,共4页Journal of Wuhan Institute of Technology

基　　金：国家"十二五"科技支撑计划资助项目(2012BA07B03);国家自然科学基金资助项目(51144003);第七届校长基金资助项目

摘　　要：针对湿法提钒工艺排放的含钒废水特点,采用硫酸亚铁作为还原剂,使废水中的高价钒还原,其氧化产物再作为沉淀剂与还原产物反应,使废水中各种形态的钒沉淀.在碱性条件下,生成的Fe(OH)2和Fe(OH)3还可作为絮凝剂加速沉淀,从而达到去除钒的目的.考察了反应时间,搅拌速率,废水的pH和FeSO4的用量等对钒去除率的影响,同时也对去除机理进行了探讨.发现当含钒废水为50 mL时(含钒167.7mg/L),5 000mg/L的FeSO4用量为19mL,搅拌速率为100r/m,待反应30min后,再用NaOH将废水的pH调至9.0,处理后的含钒废水中钒的去除率可达96%以上.A treatment technique for dealing with the vanadium contained water was developed according to the water＇s properties. Ferrous sulfate was utilized as reducing agent to reduce high valence vanadium, and its oxidization could react with the reducing product to precipitate vanadium in different valence. Under the alkaline condition, the formed Fe（OH）2 and Fe（OH）3 could be used as flocculant to accelerate the precipitation, thus vanadium in the waste water was removed. The reaction time, stirring speed, pH of waste water and the amount of FeSO4 were examined on the removing effect of vanadium, meanwhile the removing mechanism was also discussed. It is found that when the waste water is 50 mL （V. 167.7 mg/L）, 19 mL 5 000 mg/L of FeSO4 is added to the water and after reaction for 30 min at stirring speed 100 r/m, then NaOH is used to modulate the pH to 9.0 of the water, the removing rate for vanadium is up to 96%.

关 键 词：含钒废水 硫酸亚铁 沉淀法 氧化还原反应 

分 类 号：X703[环境科学与工程—环境工程]