内螺纹管内超临界水的流动阻力特性试验研究  

Experimental Study on Flow Resistance of Supercritical Pressure Water in an Internally Ribbed Tube

作　　者：张伟强[1] 李会雄[1] 张庆[1] 雷贤良[1] 张一帆[1] 迟浩淼[1] 贾敏悦[1] 

机构地区：[1]动力工程多相流国家重点实验室(西安交通大学),陕西省西安市710049

出　　处：《中国电机工程学报》2013年第17期1-7,4,共7页Proceedings of the CSEE

基　　金：国家重点基础研究发展计划项目(973计划)(2009CB219805);国家自然科学基金项目(50876090)~~

摘　　要：在压力22.5~28MPa,质量流速600~1000kg·m-2·s-1,工质比焓800~3100 kJ·kg-1范围内,对超临界水在四头内螺纹管内的流动阻力特性进行了试验研究,得到了不同工况下内螺纹管流动阻力的变化规律,分析了压力、质量流速和工质比焓变化对内螺纹管摩擦阻力系数的影响。试验结果表明：超临界压力下质量流速对摩擦阻力压降有很大影响,但对摩擦阻力系数的影响很小;在拟临界区域摩擦阻力系数有阶跃式增长现象,且这种阶跃增长现象随着压力的增加而减弱。整理试验数据得到超临界水的内螺纹管摩擦阻力系数经验关联式,与试验值相比误差小于15%,为设计具有良好水动力特性的超临界锅炉提供可靠依据。The flow resistance characteristics of water in an internally ribbed tube was studied experimentally at different pressures from 22.5 to 28 MPa, mass fluxes from 600 to 1 000 kg.m-2.s-1, and bulk fluid enthalpy from 800 to 3100kJ.kg-l. The variation of flow resistance was obtained and the effects of pressure, mass flux and bulk fluid enthalpy on the frictional flow resistance coefficient of the internally ribbed tube were analyzed. The experimental results show that under supercritical pressures, with increasing mass flux, the frictional resistance pressure drop increases rapidly while the change of frictional resistance coefficient is little. A step growth of the frictional flow resistance coefficient occurs when the bulk fluid temperature is near the pseudo-critical temperature. The step growth phenomenon decreases with increasing pressure. On the basis of the test data, the practical corresponding empirical correlations of the frictional resistance coefficient were presented with a possible error below 15% compared with experimental measurements. The empirical correlations may confidently be used to design supercritical boiler with good hydrodynamic characteristic.

关 键 词：超临界锅炉 内螺纹管 流动阻力 摩擦阻力系数 拟临界温度 

分 类 号：TK121[动力工程及工程热物理—工程热物理]