真空冷冻预干燥对压差膨化干燥果蔬脆片质地特性的影响  

Effects of vacuum freezing pre-drying on the textural properties of explosion puffing dried fruit and vegetable crisps

作　　者：刘春菊[1] 项可心 李越 李大婧[1] 吴海虹[1] 牛丽影[1] 赵邯 于蕊 LIU Chunju;XIANG Kexin;LI Yue;LI Dajing;WU Haihong;NIU Liying;ZHAO Han;YU Rui(Institute of Agricultural Products Processing,Jiangsu Academy of Agricultural Sciences,Nanjing 210014,China;Food Science College,Shenyang Agricultural University,Shenyang 110161,China)

机构地区：[1]江苏省农业科学院农产品加工研究所,南京210014 [2]沈阳农业大学食品学院,沈阳110161

出　　处：《农业工程学报》2024年第2期144-154,共11页Transactions of the Chinese Society of Agricultural Engineering

基　　金：江苏省重点研发计划(现代农业)项目(BE2023316);江苏省农业科技自主创新资金项目(CX(22)3176)。

摘　　要：为探索预干燥处理对不同果蔬脆片结构及质地特性的影响,该研究采用真空冷冻干燥作为预干燥,并选取了3个水分转换点(60%、45%、30%),对预干燥过程中6种典型果蔬(苹果,梨,桃,山药,马铃薯,青萝卜)水分状态、细胞结构、收缩率、孔隙度、应力-松弛特性与质地特性进行测定与分析。结果表明,随着预干燥的进行,水分含量逐渐降低,自由水逐渐散失,以不易流动水为主,收缩率逐渐减小,孔隙度逐渐增大,硬度、咀嚼性、弹性模量逐渐增加;水分转换点为60%时不同果蔬脆片具有较高的硬脆度,其中马铃薯与山药脆片硬度较高,桃与梨的脆片脆度较高;水分转换点为30%时,6种果蔬的孔隙度最高,且青萝卜的孔隙度显著高于其他果蔬(P <0.05);在干燥后期,果蔬样品骨架基本形成,且收缩率较低,致使内部孔隙度变大;由相关性分析可知真空冷冻预干燥过程中水分转换点、孔隙度与果蔬脆片质地特性极显著相关(P <0.05),研究结果可为预干燥对果蔬脆片质地影响提供参考。Explosion puffing drying is well known as one of the most novel processing of food products.The raw materials are also required to be pre-dried at the given moisture content.A preferred combination of vacuum freeze-drying and explosion puffing drying can be utilized to produce the crispy products of fruit and vegetable with better color and higher brittleness.Among them,vacuum freeze-drying can be used to maintain a better shape,and then form a more loose porous structure in the dried samples.This study aims to explore the effect of pre-drying treatment on the structural and textural properties of different fruit and vegetable crisps after vacuum freeze-drying combined with explosion puffing drying.Three moisture conversion points were also selected(60%,45%,and 30%moisture content in wet base).The moisture status,cell structure,shrinkage,porosity,stress-relaxation properties,and texture profile analysis(TPA)were analyzed for the pre-dried samples.The drying time,energy consumption,and texture properties were determined for the dried crisp samples.The results showed that the moisture content gradually decreased,and the free water gradually disappeared with the pre-drying,while the immobilized water was the main component of water in the samples.The decreased degree of free water content presented a significant difference among different fruit and vegetable slices,when the vacuum freeze-drying to 60%moisture content.The free water contents of apples,peaches,pears,and potatoes decreased by 94.94%,89.76%,91.53%,and 99.49%,respectively.A large amount of free water was removed from the pre-dried samples during the early drying stage.The shrinkage rate of dried crisps decreased gradually,as the water conversion point continued to decrease,whereas,there was an increase in the porosity,hardness,chewiness,and elastic modulus.The higher shrinkage ratios were found in the crisps of apple,peach,and pear,compared with the rest.The higher hardness was found in the crisps of potato and yam.Green radish crisps shared the more sev

关 键 词：预干燥 真空冷冻干燥 压差膨化干燥 果蔬脆片 质地特性 

分 类 号：TS255.3[轻工技术与工程—农产品加工及贮藏工程]